Instruction Manual I CRRFTSMRN°J 25cc/1.5 cu.in. 2-Cycle 17 Inch Cutting Path / 0.080 In. Line GASOLINE WEEDWACKER ® Model No. C944.511463 • • • • • Safety Assembly Operation Maintenance Parts List • Fran(_ais WARNING: Read and follow all Safety Rules and Operating Instructions before first use of this product. For answers to your questions about this product: Call 7 am-7 pm, Mon.-Sat., or 10 am-7 pm, Sun. 1-800-235-5878 Sears Canada, 530163453 10/9/02 l,ours Inc.
Warranty Statement Safety Rules Assembly Operation Maintenance Service & Adjustments 2 2 4 5 8 9 LIMITED TWO (2} YEAR WARRANTY WEEDWACKER _ LINE TRIMMER Storage Troubleshooting Chart Emissions Statement Parts List French Parts and Ordering 10 11 12 14 16 Back Cover ON CRAFTSMAN ® GAS POWERED For two (2) years from the date of purchase, Sears Canada, Inc., will repair or replace free of charge at Sears option parts which are defective as a result of material or workmanship.
Keep children, bystanders, and animals 50 feet (15 meters) away, Stop unit immediately if approached, If situations occur which are not covered in this manual, use care and good judgment. If you need assistance, contact your Sears Service Centre or call 1-800-235-5878. OPERATOR SAFETY • Dress properly. Always wear safety glasses or similar eye protection when operating, or performing maintenance, on your unit (safety glasses are available). Eye protection should be marked Z87.
• Store unit and fuel in area where fuel vapors cannot reach sparks or open flames from water heaters, electric motors or switches, furnaces, etc. • Store unit so line limiter blade cannot accidentally cause injury. The unit can be hung by the tube. • Store unit out of reach of children.
KNOW YOUR TRIMMER READ THiS INSTRUCTION MANUAL AND SAFETY RULES BEFORE OPERATING YOUR UNIT. Compare the illustrations with your unit to familiarize yourself with the location of the various controls and adjustments. Save this manual for future reference. Assist Handle Tube Muffler _ ON/STOP Throttle Trigger Switch \ _- Starter f _;_'z/_ Trimmer Head Spark Plug / Shield Fit_l_aMpX Line Limiter Blade ON/STOP SWITCH The ON/STOP switch is used to stop engine.
To avoid engine problems, empty the fuel system before storage for 30 days or longer. Drain the gas tank, start the engine and let it run until the fuel lines and carburetor are empty. Use fresh fuel next season. Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur. See the STORAGE section for additional information. HOW TO STOP YOUR UNIT • To stop the engine, press and hold the ON/STOP switch in the STOP position.
To advance line: • Operate the engine at full throttle. • Hold the trimmer head parallel to and above the grassy area. • Tap the bottom of the trimmer head lightly on the ground one time. Approximately 2 in. (5 cm) of line will be advanced with each tap. Toadvance line, tap bottom of trimmer head on ground one time. OPERATING INSTRUCTIONS OPERATING POSITION ALWAYS WEAR: Long Pants Heavy Shoes _lrnp/i_e_t_uts I_ to_, / Cut from your right to your left.
orshrubs andscarfences. Tohelp around trees, posts, monuments, etc. avoiddamage especially todelicate This technique increases line wear. vegetation ortreeswithtenderbark, Scalping ....... , shorten lineto4-5in.(10-13cm) anduseatlessthanfullthrottle. • Fortrimming orscalping, useless thanfullthrottletoincrease linelife anddecrease headwear,especially: MOWING - Your trimmer is ideal for • During lightdutycutting.
CHECK FOR DAMAGED OR WORN PARTS Contact Sears Service Centre for replacement of damaged or worn parts. • ON/STOP Switch - Ensure ON/STOP switch functions properly by pressing the switch to the STOP position. Make sure engine stops; then restart engine and continue. • Fuel Tank - Discontinue use of unit if fuel tank shows signs of damage or leaks. • Debris Shield - Discontinue use of unit if debris shield is damaged.
CARBURETOR ADJUSTMENT _WARNING: Keep ethers away when making idle speed adjustments. The trimmer head will be spinning during this procedure. Wear your protective equipment and observe all safety precautions. The carburetor has been carefully set at the factory. Adjustments may be necessary if you notice any of the following conditions: • Engine will not idle when the throttle is released.
TROUBLESHOOTING TABLE WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit. TROUBLE CAUSE REMEDY Engine will not start. 1. Engine flooded. 1. See "Starting a Flooded Engine" in Operation Section. 2. Fill tank with correct fuel mixture. 3. Install new spark plug. 4. Check for dirty fuel filter; replace. Check for kinked or split fuel line; repair or replace. 5.
YOUR WARRANTY RIGHTS AND OBLIGATIONS: The U. S. Environmental Protection Agency/Environment Canada and Sears Canada, Inc., are pleased to explain the emissions control system warranty on your year 2001-2004 small off-road engine.
centers. Call1-800-665-4455. MAINTENANCE, REPLACEMENT AND REPAIR OF EMISSION RELATED PARTS: Any Sears Canada approved replacement part used in the performance of any warranty maintenance or repair on emission related parts will be provided without charge to the owner if the part is under warranty. EMISSION CONTROL WARRANTY PARTS LIST: Carburetor, Ignition System: Spark Plug (covered up to maintenance schedule), Ignition Module.
