INSTRUCTION MANUAL | GUIDE D’UTILISATION | MANUAL DE INSTRUCTIONES AIR COMPRESSOR COMPRESOR DE AIRE COMPRESSEUR D’AIR CMXECXA0200141A IF YOU HAVE QUESTIONS OR COMMENTS, CONTACT US. POUR TOUTE QUESTION OU TOUT COMMENTAIRE, NOUS CONTACTER. SI TIENE DUDAS O COMENTARIOS, CONTÁCTENOS. 1-888-899-0146 1-888-331-4569 WWW.CRAFTSMAN.
ENGLISH Definitions: Safety Alert Symbols and Words This instruction manual uses the following safety alert symbols and words to alert you to hazardous situations and your risk of personal injury or property damage. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in . WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in . CAUTION: Indicates a potentially hazardous situation which, if not avoided, may result in .
ENGLISH Air Compressor CMXECXA0200141A SAVE ALL WARNINGS AND INSTRUCTIONS FOR FUTURE REFERENCE WARNING: This product can expose you to chemicals including lead which is known to the State of California to cause birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. DANGER: RISK OF EXPLOSION OR FIRE What can happen It is normal for electrical contacts within the motor and pressure switch to spark.
ENGLISH What can happen Failure to properly drain condensed water from air tank, causing rust and thinning of the steel air tank. How to prevent it Drain air tank daily or after each use. If air tank develops a leak, replace it immediately with a new air tank or replace the entire compressor. Modifications or attempted repairs to the air tank. Never drill into, weld, or make any modifications to the air tank or its attachments. Never attempt to repair a damaged or leaking air tank.
ENGLISH Attempting to operate compressor with damaged or missing parts or attempting to repair compressor with protective shrouds removed can expose you to moving parts and can result in serious injury. Any repairs required on this product should be performed by authorized service center personnel. WARNING: RISK OF UNSAFE OPERATION What can happen Unsafe operation of your air compressor could lead to serious injury or death to you or others.
ENGLISH UNPACKING INSTALLATION How To Set Up Your Unit Location of the Air Compressor • • • Locate the air compressor in a clean, dry and well ventilated area. The air compressor should be located at least 12" (30.5 cm) away from the wall or other obstructions that will interfere with the flow of air. The air compressor pump and shroud are designed to allow for proper cooling. The ventilation openings on the compressor are necessary to maintain proper operating temperature.
ENGLISH 4 in the On(I) On(I)/Off(O) Switch: position to provide automatic power to the pressure switch Pressure Switch (not shown): The pressure switch automatically starts the motor when the air tank pressure drops below the factory set “cut-in” pressure.
ENGLISH How to Start 1. Fig. C to “On” and allow tank pressure to build. Motor will stop when tank pressure reaches 2. 8 clockwise to increase pressure MAINTENANCE WARNING: To reduce the risk of serious personal injury, turn unit off and disconnect it from power source before making any adjustments or removing/installing attachments or accessories. WARNING: Risk of unsafe operation. Unit cycles automatically when power is on.
ENGLISH Repairs Fig. D WARNING: To assure product SAFETY and RELIABILITY, repairs, maintenance and adjustment (including brush inspection and replacement, when applicable) should be performed by a CRAFTSMAN factory service center or a CRAFTSMAN authorized WARNING: Risk of Unsafe Operation. Unit cycles automatically when power is on. When servicing, you may be exposed to voltage sources, compressed air, or moving parts.
ENGLISH Accessories WARNING: Since accessories, other than those offered by CRAFTSMAN, have not been tested with this product, use of such accessories with this tool could be hazardous. To reduce the risk of injury, only CRAFTSMAN recommended accessories should be Recommended accessories for use with your tool are available at extra cost from your local dealer or authorized service center. If you need assistance in locating any accessory, please contact CRAFTSMAN, call 1-888-899-0146 or 1-888-331-4569.
ENGLISH TROUBLESHOOTING WARNING: Risk of Unsafe Operation. Unit cycles automatically when power is on. When servicing, you may be exposed to voltage sources, compressed air, or moving parts. Before servicing unit unplug or disconnect PROBLEM CAUSE Excessive tank pressure - safety valve Pressure switch does not shut off pops off. motor when compressor reaches "cutout" pressure. Pressure switch "cut-out" too high.