Cut Sheet

ManualsBrandsCRC ManualsChemicals & Cleaning SuppliesAIR BRAKE ANTI FREE

SAFETY DATA SHEET

1. Identification

Product identifier Air Brake Anti-Freeze & Conditioner

Other means of identification

Product code

05528, 05555

Recommended use

Air brake anti-freeze

Recommended restrictions

None known.

Manufacturer/Importer/Supplier/Distributor information

Manufactured or sold by:

Company name

CRC Industries, Inc.

Address

885 Louis Dr.

Warminster, PA 18974 US

Telephone

General Information

215-674-4300

Technical

Assistance

800-521-3168

Customer Service

800-272-4620

24-Hour Emergency

800-424-9300 (US)

(CHEMTREC)

703-527-3887 (International)

Website

www.crcindustries.com

2. Hazard(s) identification

Category 2Flammable liquids

Physical hazards

Category 3Acute toxicity, oral

Health hazards

Category 3Acute toxicity, dermal

Category 3Acute toxicity, inhalation

Category 2Reproductive toxicity

Category 1Specific target organ toxicity, single exposure

Not classified.

Environmental hazards

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Highly flammable liquid and vapor. Toxic if swallowed. Toxic in contact with skin. Toxic if inhaled.

Suspected of damaging fertility or the unborn child. Causes damage to organs (eyes, central

nervous system).

Precautionary statement

Prevention

Obtain special instructions before use. Do not handle until all safety precautions have been read

and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Keep

container tightly closed. Ground/bond container and receiving equipment. Use explosion-proof

electrical/ventilating/lighting equipment. Use only non-sparking tools. Take precautionary

measures against static discharge. Use only with adequate ventilation; maintain ventilation during

use and until all vapors are gone. Open doors and windows or use other means to ensure a fresh

air supply during use and while product is drying. If you experience any symptoms listed on this

label, increase ventilation or leave the area. Do not breathe mist or vapor. Wash thoroughly after

handling. Do not eat, drink or smoke when using this product. Wear protective gloves/protective

clothing/eye protection/face protection.

1 / 9

Material name: Air Brake Anti-Freeze & Conditioner

05528, 05555 Version #: 01 Issue date: 03-24-2015

SDS US

Summary of content (9 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Air Brake Anti-Freeze & Conditioner Other means of identification Product code 05528, 05555 Recommended use Air brake anti-freeze Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Manufactured or sold by: Company name Address Telephone General Information Technical Assistance Customer Service 24-Hour Emergency (CHEMTREC) Website CRC Industries, Inc. 885 Louis Dr.
PAGE 2
Response If swallowed: Immediately call a poison center/doctor. Rinse mouth. If inhaled: Remove person to fresh air and keep comfortable for breathing. Call a poison center/doctor. If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. Wash contaminated clothing before reuse. If exposed or concerned: Get medical attention. In case of fire: Do not use water jet as an extinguisher, as this will spread the fire. Storage Store in a well-ventilated place.
PAGE 3
6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Keep out of low areas. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate protective equipment and clothing during clean-up. Do not breathe mist or vapor.
PAGE 4
US. NIOSH: Pocket Guide to Chemical Hazards Components Type Value TWA Biological limit values ACGIH Biological Exposure Indices Components Value Methanol (CAS 67-56-1) 15 mg/l 260 mg/m3 200 ppm Determinant Specimen Methanol Urine Sampling Time * * - For sampling details, please see the source document. Exposure guidelines US - California OELs: Skin designation Methanol (CAS 67-56-1) Can be absorbed through the skin.
PAGE 5
Upper/lower flammability or explosive limits 2.6 % estimated Flammability limit - lower (%) Flammability limit - upper (%) 36 % estimated Vapor pressure 133.2 hPa estimated Vapor density 1.1 (air = 1) Relative density 0.79 Solubility (water) Completely soluble. Partition coefficient (n-octanol/water) Not available. Auto-ignition temperature 725 °F (385 °C) estimated Decomposition temperature Not available. Viscosity (kinematic) Not available. Percent volatile 99.9 % estimated 10.
PAGE 6
Serious eye damage/eye irritation Direct contact with eyes may cause temporary irritation. Respiratory sensitization Not available. Skin sensitization This product is not expected to cause skin sensitization. Germ cell mutagenicity No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. Carcinogenicity This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA.
PAGE 7
14.
PAGE 8
Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Methanol (CAS 67-56-1) Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Not regulated. Safe Drinking Water Act (SDWA) Food and Drug Administration (FDA) Not regulated.
PAGE 9
Country(s) or region Philippines Inventory name Philippine Inventory of Chemicals and Chemical Substances (PICCS) United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory On inventory (yes/no)* Yes Yes *A "Yes" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(