MSDS

ManualsBrandsCRC ManualsChemicals & Cleaning SuppliesSeal Coat Urethane Coating - 11oz Aerosol Can

SAFETY DATA SHEET

1. Identification

Seal Coat® Clear Urethane CoatingProduct identifier

Other means of identification

18411

Product code

Electrical coating

Recommended use

None known.

Recommended restrictions

Manufacturer/Importer/Supplier/Distributor information

Company name

CRC Industries, Inc.

Address

885 Louis Dr.

Warminster, PA 18974 US

Telephone

General Information

215-674-4300

Technical

Assistance

800-521-3168

Customer Service

800-272-4620

24-Hour Emergency

800-424-9300 (US)

(CHEMTREC)

703-527-3887 (International)

Website

www.crcindustries.com

2. Hazard(s) identification

Category 1Flammable aerosols

Physical hazards

Liquefied gasGases under pressure

Category 2Skin corrosion/irritation

Health hazards

Category 2ASerious eye damage/eye irritation

Category 2Carcinogenicity

Category 2Reproductive toxicity (fertility)

Category 3 narcotic effectsSpecific target organ toxicity, single exposure

Category 1Aspiration hazard

Category 2Hazardous to the aquatic environment, acute

hazard

Environmental hazards

Category 3Hazardous to the aquatic environment,

long-term hazard

Not classified.

OSHA defined hazards

Label elements

Signal word

Danger

Hazard statement

Extremely flammable aerosol. Contains gas under pressure; may explode if heated. May be fatal if

swallowed and enters airways. Causes skin irritation. Causes serious eye irritation. May cause

drowsiness or dizziness. Suspected of causing cancer. Suspected of damaging fertility. Toxic to

aquatic life. Harmful to aquatic life with long lasting effects.

1 / 13

Material name: Seal Coat® Clear Urethane Coating

18411 Version #: 02 Revision date: 12-07-2016 Issue date: 06-05-2014

SDS US

Summary of content (13 pages)

PAGE 1
SAFETY DATA SHEET 1. Identification Product identifier Seal Coat® Clear Urethane Coating Other means of identification Product code 18411 Recommended use Electrical coating Recommended restrictions None known. Manufacturer/Importer/Supplier/Distributor information Company name Address Telephone General Information Technical Assistance Customer Service 24-Hour Emergency (CHEMTREC) Website CRC Industries, Inc. 885 Louis Dr.
PAGE 2
Precautionary statement Prevention Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Keep away from heat/sparks/open flames/hot surfaces. - No smoking. Do not spray on an open flame or other ignition source. Do not apply while equipment is energized. Pressurized container: Do not pierce or burn, even after use. Extinguish all flames, pilot lights and heaters. Vapors will accumulate readily and may ignite. Avoid breathing mist or vapor.
PAGE 3
5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Alcohol resistant foam. Water fog. Carbon dioxide (CO2). Dry chemical powder, carbon dioxide, sand or earth may be used for small fires only. Do not use water jet as an extinguisher, as this will spread the fire. Special protective equipment and precautions for firefighters Contents under pressure. Pressurized container may rupture when exposed to heat or flame.
PAGE 4
8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) Components Type Value acetone (CAS 67-64-1) PEL ethylbenzene (CAS 100-41-4) PEL 2400 mg/m3 1000 ppm 435 mg/m3 naphtha (petroleum), hydrotreated light (CAS 64742-49-0) PEL 100 ppm 400 mg/m3 n-hexane (CAS 110-54-3) PEL xylene (CAS 1330-20-7) PEL US. OSHA Table Z-2 (29 CFR 1910.
PAGE 5
US. AIHA Workplace Environmental Exposure Level (WEEL) Guides Components Type propylene glycol methyl ether acetate (CAS 108-65-6) TWA Biological limit values ACGIH Biological Exposure Indices Components Value acetone (CAS 67-64-1) ethylbenzene (CAS 100-41-4) Value 50 ppm Determinant 25 mg/l 0.15 g/g Acetone Sum of mandelic acid and phenylglyoxylic acid 2,5-Hexanedio n-hexane (CAS 110-54-3) 0.4 mg/l n, without hydrolysis toluene (CAS 108-88-3) 0.3 mg/g o-Cresol, with hydrolysis 0.03 mg/l Toluene 0.
PAGE 6
Odor threshold Not available. pH Not available. Melting point/freezing point -244.7 °F (-153.7 °C) estimated Initial boiling point and boiling range 118.4 °F (48 °C) estimated Flash point -4 °F (-20 °C) Tag Closed Cup Evaporation rate Fast. Flammability (solid, gas) Not available. Upper/lower flammability or explosive limits 1 % estimated Flammability limit - lower (%) Flammability limit - upper (%) 12.8 % estimated Vapor pressure 1480.
PAGE 7
Components Species Test Results Inhalation LC50 Rat 16000 ppm, 4 hours Oral LD50 Rat 5800 mg/kg Dermal LD50 Rabbit 17800 mg/kg Inhalation LC50 Rat 17.
PAGE 8
Skin corrosion/irritation Causes skin irritation. Serious eye damage/eye irritation Causes serious eye irritation. Respiratory sensitization Not a respiratory sensitizer. Skin sensitization This product is not expected to cause skin sensitization. Germ cell mutagenicity No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. Carcinogenicity Suspected of causing cancer. IARC Monographs.
PAGE 9
Components Species Test Results toluene (CAS 108-88-3) Aquatic Acute Crustacea EC50 Water flea (Daphnia magna) 6 mg/l, 48 hours Fish LC50 Coho salmon,silver salmon (Oncorhynchus kisutch) 5.5 mg/l, 96 hours LC50 Rainbow trout,donaldson trout (Oncorhynchus mykiss) 9.5 - 19.2 mg/l, 96 hours xylene (CAS 1330-20-7) Aquatic Fish * Estimates for product may be based on additional component data not shown. Not available. Persistence and degradability Bioaccumulative potential Not available.
PAGE 10
Subsidiary risk Packing group ERG Code Special precautions for user Other information Passenger and cargo aircraft Cargo aircraft only IMDG UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Packing group Environmental hazards Marine pollutant EmS Special precautions for user Not applicable. 10L Read safety instructions, SDS and emergency procedures before handling. Allowed with restrictions. Allowed with restrictions. UN1950 AEROSOLS, Limited Quantity 2 Not applicable. No.
PAGE 11
toluene (CAS 108-88-3) 6594 Drug Enforcement Administration (DEA). List 1 & 2 Exempt Chemical Mixtures (21 CFR 1310.12(c)) acetone (CAS 67-64-1) 35 %WV toluene (CAS 108-88-3) 35 %WV DEA Exempt Chemical Mixtures Code Number acetone (CAS 67-64-1) 6532 toluene (CAS 108-88-3) 594 FEMA Priority Substances Respiratory Health and Safety in the Flavor Manufacturing Workplace acetone (CAS 67-64-1) Low priority Not regulated.
PAGE 12
US. California Proposition 65 WARNING: This product contains a chemical known to the State of California to cause cancer and birth defects or other reproductive harm.
PAGE 13
NFPA ratings 4 2 Disclaimer Revision Information 0 The information contained in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. This information is accurate to the best of CRC's knowledge or obtained from sources believed by CRC to be accurate. Before using any product, read all warnings and directions on the label.