Ovens FL-2340-D Rev. 0 (5/13) Page 1 of 12 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION, OPERATION and MAINTENANCE MANUAL for Cres Cor RADIANT OVENS 1000-CH-SS-SPLIT-D 1000-CH-AL-SPLIT-D 1000-CH-SS-SPLIT-D120 1000-CH-SS-D 1000-CH-AL-D Models: 1000-CH-D SERIES Cabinet model number: Cabinet serial number: Authorized Service Agency: Ph: Fax: Keep this manual for future reference. Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
Ovens FL-2340-D Rev. 0 (5/13) Page 2 of 12 5925 Heisley Road • Mentor, OH 44060-1833 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS....................................................................................... 3, 4 OPERATING INSTRUCTIONS............................................................................................. 5, 6 Illustration, Control Panel.............................................................................................
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2340-D Rev. 0 (5/13) Page 3 of 12 INSTALLATION INSTRUCTIONS VENTING YOUR OVEN: 1. The purpose of ventilating hoods is to direct and capture smoke, grease-laden vapors, heat, odors, or fumes. 2. Low temperature equipment (maximum temperature 250°F/121°C) does not produce heat, odors, fumes, grease-laden vapors or smoke and is not required to be vented. 3.
Ovens FL-2340-D Rev. 0 (5/13) Page 4 of 12 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS (continued) IDENTIFYING YOUR CABINET: Look for this label on the back of your cabinet. This information is needed when calling for questions or service. R 5925 HEISLEY RD. MENTOR, OHIO 44060 C US PL E MOD. 1000CH R SER. FAA-K5645C-001 Hz. 60 AMPS 29 M R 208/240 3000 SA VOLTS WATTS PH.
925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2340-D Rev. 0 (5/13) Page 5 of 12 OPERATING INSTRUCTIONS HOW TO USE THE COOK-N-HOLD CONTROL: *Push the lighted switch on the control panel; the light will come on and the cabinet will start heating. *The display will read “LOTPR” (low temperature) below 140°F. (60°C.). NOTE: Wait one (1) hour after start up before loading the food for best results. The display will read “PREHT” until the cabinet reaches the set temperature, then it will show “READY”.
5925 Heisley Road • Mentor, OH 44060-1833 RECIPES: The control can hold up to 18 saved recipes. To save a recipe: 1. Press and hold both the TIME button and the knob for 5 seconds. The screen will be flashing. This is the setup menu. 2. Turn the knob through the menu until you get to “Edit”. 3. Press the knob and turn to the recipe you want to edit. There are 18 blank recipes to customize and save. 4. Press the knob and enter the cook, hold and time values. 5.
Ovens FL-2340-D Rev. 0 (5/13) Page 7 of 12 5925 Heisley Road • Mentor, OH 44060-1833 HOW TO CLEAN THE UNIT: WARNING BEFORE cleaning the cabinet: 1. 2. 3. 4. Unplug cord from wall. Allow cabinet to cool. Do NOT hose cabinet with water. Do NOT get water on controls. Do NOT use abrasives or harsh chemicals. Wipe up spills as soon as possible. Clean regularly to avoid heavy dirt build-up. Cleaning Hints: 1. Use the mildest cleaning procedure that will do the job. 2.
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2340-D Rev. 0 (5/13) Page 8 of 12 MAINTENANCE INSTRUCTIONS TROUBLE-SHOOTING GUIDE WARNING IF UNIT GETS TOO HOT OR WON’T SHUT OFF, DISCONNECT POWER AT BRANCH PANEL. DO NOT UNPLUG CORD! If hot unit is NOT working, first check the following causes: 1. Cord is unplugged from wall outlet. 3. Switch(es) are turned off. 2. Circuit breaker/fuse to wall outlet is blown. 4. Thermostat(s) are turned off, or are set too low.
Ovens FL-2340-D Rev. 0 (5/13) Page 9 of 12 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS Include all information on nameplate when ordering parts 7 8 9 24 23 27 28 4 3 2 22 5 1 6 26 INSULATION 18 14 11 12 12 29 SIDE PANEL 16 19 13 10 25 21 17 15 HEATER WIRE COVER Model 1000-CH-SS-D is shown. Model 1000-CH-SPLIT-D is half-size single door oven. Call Toll-free: 877-CRES COR (273-7267)FL-2340D • Fax: 800-822-0393 • www.crescor.
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2340-D Rev. 0 (5/13) Page 10 of 12 REPLACEMENT PARTS Include all information on nameplate when ordering parts ITEM DESCRIPTION 1. Switch (On/Off) 2. Digital Control 3. Switch, Fan 4. Relay (1000-SPLIT-D) Relay (1000-SS-D) 5. Terminal Block (Input) 6. Terminal Block 7. Switch, toggle (240V) 8. Vent Fan (240V) Vent Fan (120V) 9. Fan Guard 10. Heater Kit 240V, 1325W Heater Kit 120V, 1000W 11. Door Latch Kit 12. Latch Strike Kit 13. Door Assembly 14.
18 N L N L Bottom Power Switch 17 16 15 RED 13 GRAY YELLOW PURPLE RED GRAY YELLOW PURPLE BOTTOM Transformer BLUE WHITE BROWN BLACK BLUE WHITE 20 19 18 17 25 24 25 24 N L Power Switch N L Top 23 22 31 30 K3 K1 K2 BOTTOM CABINET LOOKING AT REAR RENAU CONTROL Bottom Control Compartment Transformer BLACK BROWN 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 12 20 19 27 26 TOP TRIAD 23 27 3A 30 31 26 3A 15 14 MEAT PROBE fuse t° 21 fuse 22 bottom heaters
RED PURPLE POWER CORD GROUND* 12 VAC RED BLUE GRAY YELLOW GRAY 12 VAC YELLOW TRIAD HAMMOND BLUE BLACK WHITE BROWN ORANGE BLACK WHITE BROWN 208/240 VAC 208/240 VAC VENT FAN VENT FAN TERMINAL BLOCK blue brown TERMINAL BLOCK blue brown HIGH TEMP closes @130F 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 K3 K1 K2 AIR LOOKING AT REAR RENAU CONTROL
