Ovens FL-2340 Rev. 5 (7/08) Page 1 of 14 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION, OPERATION and MAINTENANCE MANUAL for Cres Cor RADIANT OVENS 1000-CH-SS-SPLIT 1000-CH-AL-SPLIT 1000-CH-SS 1000-CH-AL Models: 1000-CH SERIES Cabinet model number: Cabinet serial number: Authorized Service Agency: Ph: Fax: Keep this manual for future reference. Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
Ovens FL-2340 Rev. 5 (7/08) Page 2 of 14 5925 Heisley Road • Mentor, OH 44060-1833 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS ...................................................................................... 3, 4 OPERATING INSTRUCTIONS ............................................................................................ 5 Illustration, Control Panel ............................................................................................
Ovens FL-2340 Rev. 5 (7/08) Page 3 of 14 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS VENTING YOUR OVEN: 1. The purpose of ventilating hoods is to direct and capture smoke, grease-laden vapors, heat, odors, or fumes. 2. Low temperature equipment (maximum temperature 250°F/121°C) does not produce heat, odors, fumes, grease-laden vapors or smoke and is not required to be vented. 3.
Ovens FL-2340 Rev. 5 (7/08) Page 4 of 14 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS (continued) HOW TO INSTALL CABINETS: 1. Remove all packing material from the inside and all vinyl from the outside of oven. 2. Place the oven in a well ventilated area on level floor. Clearance requirements: 3” (76mm) at the back, 2” (51mm) at the top, 1” (25mm) at both sides. 3. Install the pan slide racks on the sidewalls, if necessary. 4.
Ovens FL-2340 Rev. 5 (7/08) Page 5 of 14 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS Thermostat “Hold” Timer Power Switch Thermostat “Cook” Thermometer Yellow Light FOR FIRST-TIME OPERATION ONLY: A new oven needs to “burn off” factory oils and glue before it’s first use. Do NOT load food into oven until this has been done! 1. Push switch to “ON”. 2. 3. 4. 5. Set the Cook thermostat to 325°F/163°C. Set the Hold thermostat to 150°F/66°C. Set the timer to one (1) hour.
Ovens FL-2340 Rev. 5 (7/08) Page 6 of 14 5925 Heisley Road • Mentor, OH 44060-1833 HOW TO CLEAN THE UNIT: WARNING BEFORE cleaning the cabinet: 1. 2. 3. 4. Unplug cord from wall. Allow cabinet to cool. Do NOT hose cabinet with water. Do NOT get water on controls. Do NOT use abrasives or harsh chemicals. Wipe up spills as soon as possible. Clean regularly to avoid heavy dirt build-up. Cleaning Hints: 1. Use the mildest cleaning procedure that will do the job. 2.
Ovens FL-2340 Rev. 5 (7/08) Page 7 of 14 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS TROUBLE-SHOOTING GUIDE WARNING IF UNIT GETS TOO HOT OR WON’T SHUT OFF, DISCONNECT POWER AT BRANCH PANEL. DO NOT UNPLUG CORD! If hot unit is NOT working, first check the following causes: 1. Cord is unplugged from wall outlet. 3. Switch(es) are turned off. 2. Circuit breaker/fuse to wall outlet is blown. 4. Thermostat(s) are turned off, or are set too low.
Ovens FL-2340 Rev. 5 (7/08) Page 8 of 14 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS Include all information on nameplate when ordering parts 3 9 10 1 6 5 2 ITEM DESCRIPTION 1. Switch (On/Off) 2. Knob, Thermostat & Timer 3. Timer 4. Thermometer 5. Thermostat, Cook 6. Thermostat, Hold 7. Pilot Light, Yellow 8. Pilot Light, Green 9. Switch, Fan 10. Relay 11. Contactor 12. Terminal Block (Input) 13. Terminal Block 14. Toggle Switch 15. Vent Fan 16. Fan Guard 17.
Ovens FL-2340 Rev. 5 (7/08) Page 9 of 14 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS Include all information on nameplate when ordering parts 16 15 12 14 11 28 13 27 Insulation 25 Model 1000-CH-SS is shown. 17 Model 1000-CH-SPLIT is half-size single door oven. 26 21 18 19 20 29 23 22 24 Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
127 FUSE 3A 10 128 FUSE 3A 9 TB1 122 16 47 11 12 119 120121122 52 8 7 6 4 3 2 L1 L4 3 2 L1 C2 C1 2 4 3 2 T1 T4 3 2 T1 6 1 19 54 55 56 57 63 120 58 59 60 61 65 3 7 2 62 64 4 P3 Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
16 47 11 12 P3 21 24 19 22 23 20 Fan Switch Fan Switch 21 18 16 15 14 17 22 15 23 Lower Power Switch P1 P2 12 11 17 Upper Power Switch 28 29 51 38 A A 31 29 30 38 39 40 37 28 49 32 48 36 35 OUT M L1 L2 Timer 51 50 41 OUT M L1 L2 Timer A 43 35 34 48 A Hold Hold 119 120121122 49 44 G 36 33 27 Thermostat 26 Hold G 42 Thermostat 45 Hold Roast Roast P4 Thermostat Roast 25 25 24 37 50 32 41 33 42 30 34 40 43 27 Lower control p
VENT FAN 118 119 16 HI LIMIT 17 12 12 17 11 121 122 16 4711 119 120 51 38 A 53 3 4 1 2 POWER SWITCH 118 122 4 T2 T3 T4 L3 L4 T1 L2 L1 40 38 39 120 59 58 61 64 60 65 51 L1 L2 124 123 HI LIMIT 49 48 OUT 50 M TIMER 58 59 64 65 HI LIMIT 69 SWITCH 66 48 A 43 49 G 42 84 87 86 83 82 85 90 89 88 91 93 92 44 COOK T'STAT 46 HOLD T'STAT 47 45 123 124 66 69 60 61 50 41 1 7 42 43 103 104 105 84 83 82 A B 94 95 96 97 98 99 100 101 102 93 92 9
Ovens FL-2340 Rev. 5 (7/08) Page 13 of 14 5925 Heisley Road • Mentor, OH 44060-1833 HOW TO REVERSE DOOR OPENING Models: 1000-CH Radiant Ovens HOW TO REVERSE THE DOOR 1. Pop off hinge covers with screwdriver. 2. Remove the screws from the hinges to the cabinet; remove the door and unscrew the latch strike from the oven. Keep all screws. 3. Rotate the door 180° so that the hinges are now on the left side of the door. 4.
Ovens FL-2340 Rev. 5 (7/08) Page 14 of 14 5925 Heisley Road • Mentor, OH 44060-1833 NOTES: Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.