5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2202-MP-M Rev. 1 (4/08) Page 1 of 10 INSTALLATION, OPERATION and MAINTENANCE MANUAL for Cres Cor CONVECTION and RETHERM OVENS with Microprocessor Control and Food Probe CO151FUA12 CO151F1818 RO151FUA18 CO151HUA6 CO151H189 RO151HUA9 Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
Ovens FL-2202-MP-M Rev. 1 (4/08) Page 2 of 10 5925 Heisley Road • Mentor, OH 44060-1833 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4, 5 MAINTENANCE INSTRUCTIONS How to Clean the Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2202-MP-M Rev. 1 (4/08) Page 3 of 10 INSTALLATION INSTRUCTIONS VENTING YOUR OVEN: 3. Most jurisdictions consider our low-temperature ovens (maximum temperature is 350°F/177°C) as low-heat appliances not requiring vent hoods. 4. Installation must conform with local codes. The authority having jurisdiction of enforcement of the codes will have the responsibility for making interpretations of the rules. 1.
Ovens FL-2202-MP-M Rev. 1 (4/08) Page 4 of 10 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS POWER SWITCH PRODUCT KEYS CONTROL MODE ON SETPOINTS TIME - TEMPERATURE RETHERM COOK PROBE TIMED TIME SELECT HEAT OVEN TEMP COOK START HOLD PROBE STOP SET HOLD OFF POWER Figure 1: Control Panel (For parts description, refer to page 8.) HOW TO START UNIT: (for first-time operation only) A new oven needs to “burn off” factory oils and glue before it’s first use.
925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2202-MP-M Rev. 1 (4/08) Page 5 of 10 OPERATING INSTRUCTIONS, continued: To manually end the Cook/Retherm, Probe, or Hold mode: Press the STOP button during any of the above modes and the control will end that mode. If in the Cook/Retherm or Probe mode, the control will automatically switch into the Hold mode. HOW TO OPERATE WITH FOOD: Manual (Timed mode) Operation See “HOW TO SET CONTROL” for programming instructions. 1. Push POWER switch to “ON”. 2.
Ovens FL-2202-MP-M Rev. 1 (4/08) Page 6 of 10 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS HOW TO CLEAN THE UNIT CAUTION Cleaning Hints: 1. Use the mildest cleaning procedure that will do the job. 1. ALLOW CABINET TO COOL. 2. REMOVE HOT UNIT BEFORE CLEANING. 2. Always rub in the direction of the polish lines to avoid scratching the surface. 3. Use only a soft cloth, sponge, fibrous brushes, plastic or stainless steel pad for cleaning and scouring.
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2202-MP-M Rev. 1 (4/08) Page 7 of 10 MAINTENANCE INSTRUCTIONS TROUBLE-SHOOTING GUIDE, continued PROBLEM POSSIBLE CAUSE SOLUTION Cabinet does not heat, or doesn’t heat properly 1. 2. 3. 4. 5. 6. Fuse Control Sensor Heater contactor Loose wiring at heater contactor On/Off Switch 1. 2. 3. 4. 5. 6. Replace Replace Replace Replace Replace Replace Blowers do not operate 1. 2. 3. 4. On/Off Switch Fuse Blower Control 1. 2. 3. 4.
Ovens FL-2202-MP-M Rev. 1 (4/08) Page 8 of 10 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS, continued Include all information on nameplate when ordering parts 1 2a 2a 2 MODE ON SETPOINTS TIME - TEMPERATURE RETHERM COOK PROBE TIMED TIME SELECT HEAT OVEN TEMP COOK START HOLD PROBE STOP SET HOLD OFF POWER FIGURE 2: CONTROL PANEL Hot Unit Replacement Parts ITEM DESCRIPTION Part No. 1. Switch (On/Off) 2. Microprocessor Control 2a. 5 Key Preset Module (optional) 3.
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2202-MP-M Rev. 1 (4/08) Page 9 of 10 REPLACEMENT PARTS, continued Include all information on nameplate when ordering parts 9 15 7 10 8 19 L3 T3 L2 T2 L1 T1 16 18 6 5 3 4 FIGURE 3; Hot Unit w/o Top Cover (For parts description, refer to page 8) 17 6 13 12 14 FIGURE 4; Bottom of Hot Unit, Cover Removed (For parts description, refer to page 8) Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
5925 Heisley Road • Mentor, OH 44060-1833 Ovens FL-2202-MP-M Rev. 1 (4/08) Page 10 of 10 WIRING DIAGRAM HIGH TEMP. LIMIT, LEFT 8 8 HIGH TEMP. LIMIT, LEFT 8 HIGH TEMP. LIMIT, LEFT 67 15 67 67 LEFT REAR FRONT 9 9 13 HEATERS 14 11 RIGHT REAR FRONT FRONT REAR RIGHT WIRE KIT 5812-907 HEATERS 13 11 68 12 12 68 FRONT REAR RIGHT WIRE KIT 5812-907 HEATERS 11 13 68 12 4 20 20 20 HEATER CONTACTOR 4 HEATER CONTACTOR 4 HEATER CONTACTOR HIGH TEMP.