IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment: Model #: ___________________________ Serial #: ___________________________ Date Purchased: _____________________ Installation & Operation Manual Electric Counter Pan Steamers EPX-3 & EPX-5 Model EPX-5 WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
SPECIFICATIONS Electric Counter Pan Steamers SAFETY PRECAUTIONS Before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents and problems can be caused by failure to follow fundamental rules and precautions. The following symbols, found throughout this manual, alert you to potentially dangerous conditions to the operator, service personnel, or to the equipment.
Electric Counter Pan Steamers Table of Contents RETAIN THIS MANUAL FOR FUTURE REFERENCE. Table of Contents Important Notes For Installation and Operation .................................................................... 2 Service Connections ............................................................................................................. 4 Introduction ...........................................................................................................................
Electric Counter Pan Steamers SERVICE CONNECTIONS SERVICE CONNECTIONS SERVICE CONNECTIONS – ELECTRICAL CONNECTION: Ø 1 1/8” (29 mm) hole for electrical connection. Rating to be specified on data plate. READY EZ24-5 EZ24-3 – DRAIN: 1/2” NPT COOKING TIMED COOKING OFF CONSTANT STEAM ADD WATER ELECTRICAL CHARACTERISTICS Model 1 PH 3 PH 1 PH 3 PH AMPS/PHASE 240V 1 PH 3 PH kW 208V 220V 380V 3 PH 415V 3 PH 480 V 3 PH 600V 3 PH EPX-3 9 6 43.3 28.9 25.0 N/A 40.9 27.3 23.6 N/A 37.5 25.
Electric Counter Pan Steamers INtroduction INTRODUCTION Description The model EPX-3 steamer comes equipped with a standard 9.0 kW heating block that can be reduced to 6 kW on single phase supplies. Model EPX-5 steamer comes equipped with a standard 15.0 kW heating block that can be reduced to 10 kW on single phase supplies. Your new steamer has been designed and manufactured to meet the toughest industry standards.
Electric Counter Pan Steamers INSTALLATION INSTALLATION INSTRUCTIONS Unpacking IMMEDIATELY INSPECT FOR SHIPPING DAMAGE Immediately after unpacking the steamer, check for possible shipping damage. If the steamer is found to be damaged after unpacking, save the packaging materials and contact the carrier within 15 days of delivery. File a claim regardless of extent of damage. We cannot assume responsibility for damage or loss incurred in transit.
INSTALLATION Electric Counter Pan Steamers Plumbing Connections No plumbing connections are required as steamer is filled manually. Drain Connections No drain connection is required. Water Condition For best results Crown recommends that the water supply meet the following specification: Hardness: ................................... Less than 2 grains or 35 ppm. Total Dissolved Solids (TDS): ..... Less than 60 ppm. PH Factor: ................................... 7.0 to 7.
TESTING PROCEDURES Electric Counter Pan Steamers TESTING PROCEDURES WARNING The steamer and its parts are hot. Use care when operating, cleaning or servicing the steamer. The cooking compartment contains live steam and hot water. Stay clear while opening the door. Once the steamer is installed, thoroughly test the steamer before operation. 1. Check that door opens and closes for proper operation. 2. Inspect the door gasket to ensure there is no damage. 3.
Electric Counter Pan Steamers OPERATION OPERATION Controls 1. Door Handle Move handle up to open door to cooking cavity. 2. Ready Pilot Light When lit, indicates the steamer cavity is above 150°F (65°C) and is ready for the cooking cycle. READY COOKING 3. Cooking Pilot Light When lit, indicates that a cooking cycle is in progress. 4. Timer Dial Set the cooking time (0 to 60 minutes) - steam cooking will begin after the door is closed.
OPERATION Electric Counter Pan Steamers Cooking CAUTION Live steam and accumulated hot water in the compartment may be released when the door is opened. 1. Close drain valve. 2. Remove the deflector plate to expose the bottom of the cavity. 3. Pour water through the door up to the “WATER LEVEL” mark on the back wall of the cavity and then replace the deflector plate. 4. Close the door, select “TIMED COOKING” mode with the power switch and set the timer to one minute position.
Electric Counter Pan Steamers CLEANING CLEANING WARNING Disconnect the power supply to the appliance before cleaning or servicing. WARNING Never use chlorine or bleach solution for cleaning door gasket. Never use steel wool or other metallic pads to clean the steamer. Weekly, or more often if necessary, clean the exterior with damp cloth and polish with soft dry cloth. Use a non-abrasive cleaner to remove discolourations.
COOKING GUIDELINES Electric Counter Pan Steamers COOKING GUIDELINES 1. Frozen vegetables should always be cooked in perforated 12” x 20” x 2-1/2 “ (1/1 65 mm) pans, 7-1/2 lbs. (3.4 kg) maximum per pan. 2. Frozen entrees should be underlined with a perforated pan for best results. If they are defrosted first, the heating time will be decreased. 3. Fresh foods may also be cooked in this unit.
Electric Counter Pan Steamers PREVENTIVE MAINTENANCE PREVENTIVE MAINTENANCE A good preventive maintenance program begins with the daily cleaning procedure. Additional preventive maintenance operations are presented in this section. In establishments that employ full-time maintenance personnel, the tasks described can be assigned to them. For other installations, tasks requiring mechanical or electrical experience should be performed by an authorized service agency.
Electric Counter Pan Steamers PREVENTIVE MAINTENANCE Removal of Scale Deposits WARNING Disconnect the power supply to the appliance before cleaning or servicing. It is recommended that your steamer be descaled once a week. Your steamer comes with a sixteen weeks supply of Middleby QuickClean Scale Control product (16 oz. container). QuickClean is a safe and efficient way to maintain a scale-free environment for your steamer. Weekly descaling will enhance the life of your steamer.
Electric Counter Pan Steamers TROUBLESHOOTING Troubleshooting General PROBLEM PROBABLE CAUSE 1. COOKING INDICATOR LIGHT FAILS TO LIGHT WITH TIMER SET. REMEDY a. Main power circuit breaker tripped. Locate external circuit breaker for incoming power and place in ON position. b. Door interlock switch contacts not closed. Shut cooker door to close switch contacts. Check alignment of door with switch. c. Door interlock switch faulty. Replace switch. d. Indicator light burned out. Replace light. e.
Electric Counter Pan Steamers TROUBLESHOOTING Timer Motor A defective timer motor will cause continuous operation in the TIME mode, with the timer dial failing to return to the “0 - Minute” position. To confirm timer motor condition, proceed as follows: 1. Carefully check motor wire leads and tighten loose connections. 2. Turn on power to the steamer. 3. Set timer dial (any setting beyond “0 - Minute”). If operation is correct, the motor will turn the dial toward “0 - Minute”.
Electric Counter Pan Steamers TROUBLESHOOTING Door Gasket Check gasket for cuts and replace if necessary. Door Gasket Replacement The cooking compartment door gaskets are made of a silicone-type rubber material that is very durable but subject to wear during normal operation. Should the gasket leak replace it. 1. Open the cooking compartment door. 2. Remove the six or eight screws from the gasket plate in the door panel assembly. 3. Remove the gasket plate and the door gasket from door panel. 4.
Electric Counter Pan Steamers Notes PAGE 18 OF 20 INSTALLATION & OPERATION MANUAL 10211 REV 0 (04/21)
Electric Counter Pan Steamers Notes INSTALLATION & OPERATION MANUAL 10211 REV 0 (04/21) PAGE 19 OF 20
Electric Counter Pan Steamers EPX-3 & EPX-5 Electric Counter Pan Steamers A product with the Crown name incorporates the best in durability and low maintenance. We all recognize, however, that replacement parts and occasional professional service may be necessary to extend the useful life of this appliance. When service is needed, contact a Crown Authorized Service Agency, or your dealer. To avoid confusion, always refer to the model number, serial number, and type of your appliance.
