Use and Care Manual

Do not lay the cooler on its side.The system must be in an upright position at all times. When carrying, do not lift the system by the faucets/•
spouts.
Thesystemneedstobeinstalledbyalicensedplumberinanystateorcountry;however,thefollowingstatesspecicallyrequirealicensed•
plumber to install the system OR allow a state-registered installer or contractor: AR, CA, GA, KS, MA, MI, MN, OK, RI, SC, SD, TX, VT, and
WI.
Apressureregulator,suchasaslow-owregulator,mustbeinstalledinfrontoftheunit’swaterinletifthewaterpressure(includingany•
possible pressure spikes) could exceed 60 psig. Failure to comply will void the warranty. Crystal Quest
®
accepts no liability for damage
caused by excessive water pressure or improper installation.
Installation must be made within a protected area covered from the elements and freezing. The unit must be protected from rain, dust, •
ooding,snow,freezing,anddirectsunlight(thesystem’sdirectexposuretosunlightmaycausealgaegrowthinthetankreservoir).Failure
to comply will void the warranty.
Use only ¼” OD tubing to connect the cold water supply to the system.•
Checkalltheconnections(i.e.,waterhose/tubing,connectors/ttings)toensureproperconnectionandavoidleaks.•
Checkplumbinginletandoutlettoensuretheproperowofwaterthroughthesystem.•
Plug the system into a 110 volt grounded outlet which contains a fuse or circuit breaker of 20 amps.•
Locate the system near a cold water supply line. Do not set the system farther than 15 ft. from the cold water line. Use copper tubing to •
avoid water line puncture and rodent bites. Failure to do so may cause major property damage. Crystal Quest
®
accepts no liability for
damage.
Install the system in a well-ventilated area where the temperature is consistently above 60ºF.•
System must have a 2” clearance on all sides to ensure proper ventilation.•
Install the auto shut-off valve to control and reduce the cold water supply line pressure to 25 psi and maintain at 25 psi to avoid bursting.•
Hotwatertankmustbelledwithwaterbeforetheheatingon/offswitchisturnedon.•
Do not use the system on cold water supply line with less than 20 psi.•
Donotmovethecooleriflledwithwater.•
Important Information .........................................................................................................................................................................2
SystemSpecications(Turbo/Sharp) ..................................................................................................................................................3
SystemSpecications(Elegant/Hybrid) ..............................................................................................................................................4
Installation Instructions ................................... ....................................................................................................................................5
Circuit and Installation Diagrams ........................................................................................................................................................6
Install Water Cooler System to Water Supply ......................................................................................................................................7
Service Information and Guidelines .....................................................................................................................................................8
Replacement Cartridges ......................................................................................................................................................................9
Troubleshooting Guide (Water Problems) ...........................................................................................................................................10
Troubleshooting Guide (Unit Problems) ..............................................................................................................................................11
Access to Parts Inside the System ......................................................................................................................................................12
Water Cooler Heating Reservoir Replacement Guide .........................................................................................................................13
Water Coolers (Optional Cartridges & Accessories) ............................................................................................................................14
System Warranty .................................................................................................................................................................................15
Ordering Replacement Cartridges .......................................................................................................................................................16
Important Information
Table of Contents
2