Operator`s manual

21se c t i O n 6 — Ma i n t e n a n c e & ad j u s t M e n t s
Hydrostatic Transmission
Your zero turn tractor is equipped with dual integrated
hydrostatic pumps/transaxles that are sealed and are

transmission oil expansion reservoir. Under normal operating
conditions, the oil level in the expansion reservoir does not need
to be checked and no additional oil is needed. If checking the
reservoir oil level, proceed as follows:
WARNING! 
starting the tractor when the transmission oil is fully
cooled.

cap and the area around the cap to prevent debris from

Turn the reservoir cap counterclockwise to re-move, then 2.




If necessary to add oil because of some type of leakage, use 


tighten.
Cleaning the Tractor
Any fuel or oil spilled on the machine should be wiped off


part of the machine, especially the belts and pulleys.
Smart Jet™

part of its deck wash system.

underside and prevent the buildup of corrosive chemicals.

2.
To prevent gum deposits from forming inside a.

malfunction of the engine, the fuel system must be
either completely emptied, or the gasoline must be
treated with a stabilizer to prevent deterioration.
WARNING! Fuel left in the fuel tank deteriorates
and will cause serious starting problems.
Using a fuel stabilizer:b.

and recommendations.
Add to clean, fresh gasoline the correct 
amount of stabilizer for the capacity

Fill the fuel tank with treated fuel and run the 

into the carburetor.
Emptying the fuel system:c.

fuel consumption with the goal of running
the fuel tank empty.
Run the engine until it begins to stall. Use the 
choke to keep the engine running until all fuel
in the carburetor has been exhausted.
Referring to the engine manual, drain the fuel 
from the carburetor bowl.
Clean the engine and the entire tractor thoroughly.
Fully charge the battery, then disconnect the negative 4.
cable at the battery to prevent possible discharge.
Recharge the battery periodically when in storage.
NOTE: Remove the battery if exposed to prolonged periods

where temperatures are above freezing.
Lubricate all lubrication points.5.
NOTE: Use a pressure washer or garden hose is not
recommended to clean your tractor. They may cause
damage to electrical components, spindles, pulleys,
bearings or the engine. The use of water will result in
shortened life and reduce serviceability.
Removing The Tractor From Storage
Check the engine oil.
Fully charge the battery and inflate the tires to the 2.
recommended pressure.
If drained before storing, fill the fuel tank with clean, fresh 
gasoline.
Add clean, fresh fuel.4.
5.
ensure engine is operating properly.
Drive the tractor without a load to make certain all the 6.
tractor systems are functioning properly.
Full Cold Line
Figure 6-3