Woodcreek 4-in-1 Pellet Grill OWNER’S MANUAL OPERATING INSTRUCTIONS SAVE THIS MANUAL FOR FUTURE REFERENCE Model SMK0036AS / SMK0036ASO WARNING NOTICE TO INSTALLER: LEAVE THESE INSTRUCTIONS WITH THE GRILL OWNER FOR FUTURE REFERENCE. PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS PELLET FUEL-BURNING APPLIANCE. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH.
IMPORTANT SAFETY WARNINGS WE WANT YOU TO ASSEMBLE AND USE YOUR GRILL AS SAFELY AS POSSIBLE. THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR GRILL & SMOKER. WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS! READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR GRILL & SMOKER. WARNING Do NOT use in humid or wet conditions WARNING 1.
TABLE OF CONTENTS: General Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 Operating the Grill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10 Proper Care and Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Transporting and Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Grill Cooking Tips . . . . . . . . . . . . . . . . . . . . . .
GENERAL WARNINGS: WARNING When using electric appliances, basic safety precautions should always be followed including the following: 3 • Operate only per manufacturers instructions. • Keep all combustible materials at least 60 inches (152.4 cm) away from the grill at all times. Do not use this grill under any overhang or near any combustible structures. • Minimum clearance from side and back of unit to combustible materials, 60 inches (152.4 cm) from side and 60 inches (152.4 cm) from back.
• This product is not designed for tabletop use. Do not set this product on a tabletop. • Outdoor extension cords must be used with outdoor use products and are marked with suffix “W” and with the statement “Suitable for Use with Outdoor Appliances.” • • • Only use a properly-grounded power source. Use only with a properly-grounded GFI (Ground Fault Interrupter) household circuit. Do not operate this product in rain or wet conditions. Do not allow this product to come in contact with water.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR PELLET GRILL & SMOKER. FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE. SAVE THIS MANUAL FOR FUTURE REFERENCE. OPERATING THE GRILL: WARNING Read and follow all warnings and instructions contained in the preceding sections of this manual.
Step 2 Make sure temperature control knob is “OFF”. Plug power Control Panel cord into a GFI (grounded) outdoor electrical outlet.
Follow these steps If the grill does not ignite or if the fire in the fire pot goes out while cooking: Step 1 Turn the temperature control knob to “OFF” and unplug. Open cooking chamber lid and remove all food, cooking grates, grease tray and heat distribution plate. CAUTION: Some parts may contain sharp edges. Wear protective gloves if necessary. WARNING: Always use oven mitts/gloves to protect your hands. Metal parts become hot during use.
OPERATING TIPS: • Your Pellet Grill should never be moved while it is hot. If you are transporting your grill in a vehicle after cooking on it, make sure the fire is completely out and the grill is cold before placing it in any vehicle. NEVER put water into the fire pot. It will jam the auger and can damage the ignitor. • The Pellet Grill is designed to operate with the lid closed. • Make sure the heat baffle is properly seated on its locating brackets.
• Griddle: 1. Place Griddle on top of cooking grates with the grease reservoir toward the back of the grill. Push the Griddle to the back of the grill. It is best to locate the Griddle near the middle of the grill. 2. Turn grill to the desired temperature and allow 15 to 20 minutes for griddle to get to desired temperature. 3. Keeping the lid closed during cooking will help Storage prevent grease splatter. 4. Grease and food particles can be pushed back into the grease reservoir while cooking. 5.
COOK MODE: • The temperature dial can be changed at any time to increase or decrease the cooking temperature of the grill. • The 200°F to 300°F temperature settings are for slow cooking/smoking. • The 325°F to 450°F temperature settings are for grilling. • The “SEAR” temperature setting is for searing. • Adjust the control knob to a desired temperature. The selected temperature will be in the bottom left hand corner of the digital display.
PROPER CARE & MAINTENANCE: • Remove wood pellets from hopper if grill will not be used for a long period of time. Wood pellets can become soggy due to moisture/humidity and can cause the auger to bind up or not push pellets to burn chamber. • Disposal of ashes – Ashes should be placed in a metal container with a tight-fitting lid. The closed container of ashes should be placed on a non-combustible floor or on the ground, well away from all combustible materials, pending final disposal.
TRANSPORTING AND STORAGE: WARNING • Never move a grill when it is hot or when objects are on the cooking surfaces. • Never store flammable liquids or spray canisters under or near the grill. • DO NOT extinguish grease fires using water. BEFORE STORING YOUR GRILL: • Clean all surfaces. • If storing the grill outdoors, close the wood pellet lid and cover the grill with a cover for protection from the weather.
TROUBLE SHOOTING: PROBLEM CAUSE LCD screen will not light up CORRECTION 2. The fuse is blown. 1. Make sure the grill is plugged into a working power source. Check and make sure wire connections are properly connected. 3. Check that the GFI outlet has not been tripped. 2. Check the fuse and see if it has blown and needs to be replaced. Use 5 Amp Fuse. 4. Control knob is in the “OFF” position. 3. Reset GFI outlet. 1. Grill is not plugged in. 4. Control knob is still in the “OFF” position.
WIRING DIAGRAM: THERMOCOUPLE POWER CORD BLACK DC 12V3A Power Supply and Control Wire WHITE POWER SUPPLY FUSE HOLER 5 Amp Fuse PURPLE WHITE FIRE POT RED WHITE IGNITOR AUGER MOTOR ORANGE WHITE BLOWER FAN BLUE WHITE GRAY GREEN YELLOW BLACK DISPLAY PANEL GRAY WHITE GREEN BLUE YELLOW BLACK BLACK PELLET SENSOR RED YELLOW POWER SUPPLY Power adapter mounted inside AUGER box 14
IC: 25523-0356 FCC ID: 2AURUJINHENG The device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause any undesired operation. FCC Warning Warning: Changes or modifications to this smoker not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment.
WARRANTY PROOF OF PURCHASE is required to access this warranty program, which is in effect from the date of purchase. Customers will be subject to parts, shipping, and handling fees if unable to provide proof of the purchase or after the warranty has expired. If you have any questions or problems, you can call our customer service department at 1-866-212-3150 from 9:00am to 5:00pm Eastern time, Monday through Friday for assistance.
