Install Manual
Table Of Contents
- Table of Contents
- 1. Important Safety Instructions
- 1.1 Warning, Caution, and Note Styles Used in This Manual
- 1.2 General Information
- 1.3 General Precautions
- 1.4 Generator Set Voltage Is Deadly
- 1.5 Engine Exhaust Is Deadly
- 1.6 Fuel and Fumes Are Flammable
- 1.7 Batteries Can Explode
- 1.8 Moving Parts Can Cause Severe Personal Injury or Death
- 1.9 The Hazards of Carbon Monoxide
- 2. Introduction
- 3. Pre-Installation Considerations
- 4. Installation
- 5. Startup and Configuration
- Appendix A. Fuel Line Selection
- Appendix B. Outline and System Drawings
- Appendix C. Seismic Requirements
4. Installation 2-2016
34 A045R241 (Issue 7)Copyright © 2016 Cummins Inc.
WARNING
Fuel leaks can lead to explosive accumulations of gas. Propane sinks
in air and can accumulate inside housings, basements and other
below-grade spaces. Prevent gas leaks and the accumulation of
gaseous fuel in the event of a leak.
Use clean, fresh HD-5 grade propane or equivalent product consisting of at
least 90% propane.
NOTICE
NFPA Standard No. 58 requires all persons handling and operating
propane to be trained in proper handling and operating procedures.
NOTICE
Commercial propane may contain more than 2.5% butane, which can
result in poor fuel vaporization and low tank pressure, resulting in poor
engine starting and operation in below 32 °F (O °C) temperatures.
Propane Tank Size
When propane is used, size the tank correctly to ensure successful generator
set operation.
Considerations when figuring the proper propane tank size:
• Temperature is a critical factor that affects the size of the tank.
◦ Ambient temperatures can affect how quickly liquid is converted to
gas.
◦ Generator set fuel consumption is the same regardless of the
surrounding temperatures.
◦ Colder weather climates require larger fuel tanks. Larger tanks have
greater surface area, allowing more liquid propane to vaporize and
maintain the required fuel rate.
◦ Propane is stored as liquid. Keep the fuel tank at least 50% full to
operate properly. Fuel tanks that are less than 50% full may not have
the capacity to vaporize enough propane to operate the generator set
and other LP appliances.
• Propane tanks are sized by their internal volume in gallons, not the
amount of fuel they can hold (which is less).
• Propane tanks are generally filled to only 80% of their capacity.
Therefore, a 500-gallon (1892-liter)tank results in 400-gallon (1514-liter)
tank capacity.
• Low ambient temperatures affect the amount of fuel available from the
propane tank.










