Use and Care Manual

Table of Contents
1. IMPORTANT SAFETY INSTRUCTIONS ...................................................................................... 1
1.1 Save These Instructions ........................................................................................................ 1
1.2 General Precautions .............................................................................................................. 1
1.3 Generator Voltage is Deadly .................................................................................................. 2
1.4 Engine Exhaust is Deadly ...................................................................................................... 2
1.5 Fuel is Flammable and Explosive .......................................................................................... 2
1.6 Batteries Can Explode ............................................................................................................ 2
1.7 Moving Parts Can Cause Severe Personal Injury or Death .................................................. 3
1.8 The Hazards of Carbon Monoxide.......................................................................................... 3
1.8.1 What Is Carbon Monoxide Poisoning? ........................................................................ 3
1.8.2 What Are the Special Risks of CO Near the Home? ................................................... 3
1.8.3 Only You Can Protect Yourself From CO Poisoning! .................................................. 4
2. INTRODUCTION............................................................................................................................ 5
2.1 About this Manual ................................................................................................................... 5
2.2 About the Generator Set......................................................................................................... 5
2.2.1 Generator Set Nameplate ........................................................................................... 6
2.2.2 Model Specifications .................................................................................................... 7
2.3 How to Obtain Service ........................................................................................................... 9
3. OPERATION ............................................................................................................................... 11
3.1 3 Position Switch................................................................................................................... 11
3.2 In-Home Operator Panel ...................................................................................................... 12
3.2.1 BACK Button .............................................................................................................. 12
3.2.2 START STOP Button ................................................................................................. 12
3.2.3 Standby ON/OFF Button............................................................................................ 12
3.3 Typical Operation.................................................................................................................. 13
3.3.1 Normal Operation: Utility Power Available and Connected ....................................... 16
3.3.2 Emergency Operation: Utility Power Interrupted ....................................................... 17
3.3.3 To Adjust the Output Voltage..................................................................................... 18
3.4 To Enable/Disable Standby ................................................................................................. 18
3.5 To Manually Start/Stop Generator Set ................................................................................ 19
3.6 Fault, Maintenance and New Event Screens ....................................................................... 19
3.6.1 Fault Screen............................................................................................................... 20
3.6.2 Maintenance Due Screen .......................................................................................... 20
3.6.3 New Event Screen ..................................................................................................... 20
3.7 Genset Status ...................................................................................................................... 21
3.8 Load Management ................................................................................................................ 22
3.8.1 Automatic Load Management .................................................................................... 23
3.8.2 Manual Load Management ........................................................................................ 23
3.9 Display Setup and Software Info .......................................................................................... 24
3.9.1 Brightness and Contrast ............................................................................................ 24
A029V089 (Issue 9) i