Troubleshooting Guide

ManualsBrandsCurtis ManualsCommercial Beverage Equipment and SystemsAutomatic Airpot Coffee Brewer with 1.6 Gallon Tank Capacity, 2.2-2.5 liter Brew Capacity, 4 Gallons Per Hour, in Stainless Steel

Service & Sales

1-800-421-6150

www.wilburcurtis.com

CURTIS AIRPOT BREWER

TROUBLESHOOTING GUIDE

D500GT12A1000

G3 Single Airpot Coffee Brewer

(Dispenser Sold Separately)

Summary of content (8 pages)

PAGE 1
CURTIS AIRPOT BREWER TROUBLESHOOTING GUIDE D500GT12A1000 G3 Single Airpot Coffee Brewer (Dispenser Sold Separately) Service & Sales 1-800-421-6150 www.wilburcurtis.
PAGE 2
PAGE 3
BREWER PARTS IDENTIFICATION WATER RELATED PART # 1. WC-826L HEAT RELATED DESCRIPTION VALVE, INLET 1.0 GPM 120V PART # 10. WC-1438-101 DESCRIPTION SENSOR, TEMPERATURE TANK 2. WC-5527K KIT, PROBE WATER LVL FITTING, ORING, NUT 11. WC-8556 HEAT SINK & TRIAC 3. WC-889-101 VALVE, DUMP LEFT 120V 12W 12. WC-904-04 HEATING ELEMENT 4. WC-3763 KIT, VALVE REPAIR (FOR WC-889, DUMP VALVE) 13. WC-522 THERMOSTAT, HI LIMIT HEATER 5. WC-29025 SPRAYHEAD, PURPLE ADVANCE FLOW 6.
PAGE 4
PARTS IMAGES 2 1 3 WC-826L WC-5527K VALVE, INLET 1.
PAGE 5
TROUBLESHOOTING INSTRUCTIONS POWER ISSUES The unit will not turn on: 5 Check the voltage at the power block, it should read: L1-L2 = 220v, L1-N = 120v, L2-N = 120v, N-G = 0v. 6 Check the voltage at the reset thermostat, it should read: between #1 & #3 = 220v and between #2 & #4 = 220v. 7 Check if the power cord is properly connected to the receptacle. If it is, proceed to STEP 4. Check the voltage at the toggle switch, it should read: between #1 & #3 = 220v and between #2 & #4 = 220v.
PAGE 6
TROUBLESHOOTING INSTRUCTIONS TANK FILLING ISSUES Not filling: Overfilling: Turn OFF toggle switch. Does the tank continue to fill? Yes: Replace water inlet valve No: Ground the probe wire to the chassis. Yes: Does the LCD read “Water Level Error”? Yes: Verify the flow rate to be a minimum of 1 gpm from outlet of the water filter. If not, ensure that the inlet side of the water filter is receiving a minimum of 1 gpm. If yes, replace the water filter. If not, consult a plumber.
PAGE 7
NOTES __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ __________________________________________________________________________________________ ___________________________________________________
PAGE 8
Wilbur Curtis Co., Inc. 6913 Acco Street, Montebello CA 90640 Customer Service: 800.421.6150 | 323.837.2300 csrassistance@wilburcurtis.com Tech Support: 800.995.0417 www.wilburcurtis.