SDS

Conforms to OSHA HazCom 2012 Standard and CPR
SAFETY DATA SHEET
Section 6: ACCIDENTAL RELEASE MEASURES
6.1 PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES
Use personal protection recommended in Section 8. Isolate the hazard area and deny entry to
unnecessary and unprotected personnel.
6.2 METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING - UP
Methods for Containment:
Pick up large pieces, then place in a suitable container. Do not flush to
sewer or allow to enter waterways. Use appropriate Personal Protective
Equipment (PPE).
Methods for Cleaning-Up:
Vacuum or sweep material and place in a disposal container.
Section 7: HANDLING AND STORAGE
7.1 PRECAUTIONS FOR SAFE HANDLING
Handling:
Avoid contact with skin and eyes. Do not swallow. Do not breathe in
dust/fumes/mist. Good housekeeping
is important to prevent
accumulation of dust. Avoid generating dust. The
use of compressed air
for cleaning clothing, equipment, etc, is not
recommended. Use only in
well-ventilated areas. Handle and open
container with care. When using
do not eat or drink. Wash hands before
eating, drinking, or smoking.
(See section 8)
General Hygiene Advice:
Launder contaminated clothing before reuse. Wash hands before
eating, drinking, or smoking.
7.2 CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES
Storage:
Keep out of the reach of children. Store in dust-tight, dry, labeled
containers. Keep containers closed when not in use. Avoid any dust
buildup by frequent cleaning and suitable construction of the storage
area. Do not store in an area equipped with emergency water
sprinklers. Use corrosion-resistant structural materials and lighting
and ventilation systems in the storage area. (See section 10)
Section 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
8.1 CONTROL PARAMETERS
Exposure Guidelines
Occupational Exposure Limits
Ingredient
OSHA-PEL
ACGIH-TLV
Portland cement
15 mg/m³ (total); 5 mg/m³ (resp)
1 mg/m³ (no asbestos and <1%
crystalline silica, respirable fraction)
Glass, oxide, chemicals
15 mg/m³ (total)
10 mg/m³ (total)
Calcium carbonate
15 mg/m³ (total); 5 mg/m³ (resp)
10 mg/m³
Cement, Alumina,
Chemicals
Not available.
Not available.
Calcium Sulfate Anhydrite
15 mg/m
3
(total dust);
5 mg/m
3
(respirable fraction)
10 mg/m
3
Calcium Sulfate
15 mg/m
3
(total dust);
5 mg/m
3
(respirable fraction)
10 mg/m
3
Ethylene vinylacetate
copolymer
Not available.
Not available.
Trade Name: Prolite Rapid Setting Mortar
Print date: 2014-01-22
Page 4 of 10