Service manual
Cybex 600T Treadmill Service Manual
5 - Removal &Replacement
Running
Deck
NOTE: This procedure will cover the running deck, running belt, front
roller, rear roller and drive belt.
Tools Required
• Phillips head screwdriver
• 1/2
11
wrench
• 3/8
II
wrench
• Work gloves
1. Turn
the
power
off.
A. Turn the main power switch
in
the front panel
to
the off (0) position.
(It is labeled I/O).
B. Unplug the treadmill from the power outlet.
2. Remove
the
motor
cover.
A. Remove the
two
Phillips head screws that fasten the motor cover
to
the frame.
B. Lift the cover from the front and remove it from the treadmill. Set the
cover and screws aside. See Figure
1.
Figure 1
! WARNING: When
removing
the
side
rails
be
sure
to
wear
work
gloves
to
protect
against
any
sharp
edges.
Table
of
Contents
i
Read
All Instructions &Warnings
ii Important Safety Instructions
iv About This Manual
Important Voltage Information.
iv
FCC Compliance Information .
iv
V Declaration
of
Conformity
vii
Table
of
Contents
1 Safety
Warning DecaJs. . . . . . . . .
..
1-1
Caution
DecaJs
. . .
..
. . . .
..
1-2
2 Technical Specifications
Specifications . . . . . . . . . .
..
2-1
3 Preventative Maintenance
Regular
Mair1tera1ce
Activities
3-1
Running
Belt
Maintenance..
3-3
4 Troubleshooting
Test
Mode
4-1
LED
Functions. . . . . . . . .
..
4-1
Key Functions . . . . . . . . . . .
4-2
Error
Codes
. . . . . . . . . . .
..
4-2
Speed
Sensor Adjustments.
4-3
5
Removal
&Replacement
Running
Deck
. . . . . . . . . .
..
5-1
Running Belt . . . . . . . . . . .
..
5-5
Front Roller . . . . . . . . . . . .
..
5-5
Drive Belt. . . . . . . . . . . . . .
..
5-5
Rear Roller. . . . . . . . . . . . .
..
5-6
Drive
Motor.
. . . . . . . . . . .
..
5-7
Motor
Brush . . . . . . . . . .
..
5-10
Elevation
Motor
5-13
Lower Control Board
5-15
Power Cables
5-16
Une Riter 5-17
Power Switch 5-17
Power
Cord Inlet
5-18
Display Board
5-18
Heart
Rate
Board
5-20
Lower Display Board 5-21
Polar
Board 5-21
Upper
Display Cable 5-22
Lower Display
Cable
5-24
Display Overlays 5-25
6 Diagrams
Parts
Ust
. . . . . . . . . . . . .
..
6-1
Explocled
VieW
6-3
600T Schematic
6-4
7 Customer Service
Contacting Service . . . . . .
..
7-1
Serial
Number &
Voltage
....
7-1
Retum
Material
Authorization
(RMA)
7-1
Damaged Parts. . . . . . . . .
..
7-2
8 Index 8-1
Page 5-1