Service manual
Cybex
600T Treadmill
Service
Manual
C. The running belt is now free
to
remove from the treadmill.
NOTE:
If
you are reusing the same belt be sure to note which way the
belt
is
positioned before removing
it
from the treadmill.
The
directional arrow inside the belt may have rubbed off. Make a new
arrow
if
needed.
! CAUTION:
Do
not
use
a
running
belt
made
for
a
different
model
treadmill. The
belts
are
specific
for
each
treadmill
and
may
be
torn
up
or
cause
excessive
current
and
damage
the
electronics
if
used
in
combination
with
another
deck.
Running Belt
9. Position
the
running
belt
and running
deck.
A. Locate the directional arrow stamped on the inside
of
the belt. The
arrow should point the direction
of
travel. See Figure
7.
Place the
running belt
in
position.
B. Place the deck
in
position with the wax side up and then continue
with step 10.
Front Roller
10.
Attach
the
front
roller.
A. Slide the front roller into the running belt. Be sure the drive belt is
around the fly wheel drive pulley and the front roller before attaching
the front roller.
B. Loosely attach the
two
bolts and four washers that fasten the front
roller
to
the front end assembly. See Figure
6.
C. Tighten each
of
the
two
bolts evenly. Make sure not to tighten one
bolt
too
many turns before moving
to
the other bolt.
Table
of Contents
i
Read
All
Instructions &
Warnings
ii Important Safety Instructions
iv About
This
Manual
Important
Voltage
Information.
iv
FCC
Compliance Information .
iv
V
Dec
laration of Confonnity
vii
Table
of Contents
1 Safety
Warning
DecaJs . . . . . . . . .
..
1-1
Caution DecaJs . . . . . . . . .
..
1-2
2
Technical
Specifications
Specifications
2-1
3 Preventative Maintenance
Regular
Maintenance
Activities
3-1
Running
Belt
Maintenance.. 3-3
4 Troubleshooting
Test
Mode
4-1
LED
Functions. . . . . . . . . . .
4-1
Key
Functions . . . . . . . . .
..
4-2
Error
Codes. . . . . . . . . . .
..
4-2
Speed Sensor Adjustments. 4-3
5
Removal
&Replacement
Running
Deck . . . . . . . . . .
..
5-1
Running
Belt
.
..
. . . . . . . .
..
5-5
Front
Roller
. . . . . . . . . . . . . . 5-5
Drive
Belt. . . . . . . . . . . . . .
..
5-5
Rear
Roller.
. . . . . . . . . . . .
..
5-6
Drive
Motor. . . . . . . . . . . .
..
5-7
Motor
Brush . . . . . . . . . .
..
5-10
Elevation
Motor 5-13
Lower Control
Board 5-15
Power Cables 5-16
Une
Filter
5-17
Power Switch 5-17
Power Cord
Inlet
5-18
Display
Board 5-18
Heart
Rate
Board 5-20
Lower Display
Board
5-21
Polar
Board
5-21
Upper
Display
Cable
5-22
Lower Display Cable 5-24
Display
Overlays
5-25
6 Diagrams
Parts Ust . . . . . . . . . . . . .
..
6-1
Exploded
View
6-3
600T Schematic 6-4
7 Customer
Service
Contacting
Service
. . . . . .
..
7-1
Serial Number &Voltage
...
.
7-1
Retum
Material
Authorization
(RMA)
7-1
Damaged Parts.. . .
.. ..
7-2
8 Index
8-1
Page 5-5