Service manual

Cybex SOOT Treadmill Service Manual
3. Remove the heart rate board. See Figure 16.
A. Remove the
two small Phillips head screws and two spacers which
hold the heart rate board
in place.
B. Disconnect the molex connectors and ground cable from the heart
rate board.
NOTE: If you don't need to remove the handset board skip to step 6.
Lower Display Board
4. Remove the lower display board.
A. Remove the three Phillips head screws which hold the lower display
board
in place.
B. Disconnect the three cables from the lower display board.
5.
Attach the lower display board.
A. Attach the three Phillips head screws which hold the lower display
board
in place.
B. Connect the fast-on cable, ribbon cable and flextail connector
to the
lower display board. See Figure 16.
6.
Attach the heart rate board.
A. Connect the molex connectors and ground cable from the heart rate
board.
B. Attach the
two small Phillips head screws and two spacers which
hold the heart rate board
in place.
7.
Attach the console back.
A. Attach the console back and accessory holder with the eleven
screws.
Polar Board
Tools Required
• Phillips head screwdriver
1. Turn
the power off.
A.
Turn the main power switch in the front panel to the off (0) position.
Table of Contents
i Read All Instructions &Warnings
ii Important Safety Instructions
iv About This Manual
Important Voltage Information .
iv
FCC Compliance Information . iv
V Declaration of Confonnity
vii Table of Contents
1 Safety
Warning Decals. . . . . . . . .
.. 1-1
Caution Decals . . . . . . . . . . . 1-2
2 Technical Specifications
Specifications
2-1
3 Preventative Maintenance
Regular Maintenance
Activities 3-1
Running Belt Maintenance.. 3-3
4 Troubleshooting
Test
Mode . . . . . . . . . . . . .. 4-1
LED Functions . . . . . . . . . . . 4-1
Key Functions . . . . . . . . . .. 4-2
Error Codes . . . . . . . . . . . . . 4-2
Speed Sensor Adjustments. 4-3
5 Removal & Replacement
Running Deck . . . . . . . . . .
.. 5-1
Running Belt . . . . . . . . . . . .. 5-5
Front Roller . . . . . . . . . . . .
.. 5-5
Drive Belt. . . . . . . . . . . . . . . . 5-5
Rear Roller 5-6
Drive Motor . . . . . . . . . . . .
.. 5-7
Motor
Brush 5-10
Elevation Motor 5-13
Lower Control
Board 5-15
Power Cables 5-16
Une Fitter 5-17
Power Switch 5-17
Power Cord Inlet 5-18
Display Board 5-18
Heart Rate Board 5-20
Lower Display Board 5-21
Polar
Board 5-21
Upper Display Cable 5-22
Lower Display Cable 5-24
Display
Overlays 5-25
6 Diagrams
Parts Ust . . . . . . . . . . . . .
.. 6-1
Exploded View 6-3
600T Schematic 6-4
7 Customer Service
Contacting Service . . . . . . .. 7-1
SeriaJ Number & Voltage. . .. 7-1
Retum Material Authorization
(RMA) 7-1
Darnaged Parts . . . . . . . . . . . 7-2
8 Index 8-1
Page 5-21