Service manual

Cybex 600T Treadmill Service Manual
2. Remove the console back.
A. Remove the eleven Phillips head screws on the console back. Leave
the top screw which holds the accessory holder
in place. The top
screw will keep the accessory holder in place on the console back.
Set these aside. See Figure 15.
B. Locate and unplug the connector that goes from the console display
board into the the handlebar. See Figure 17.
3. Remove the left junction covers.
A. Remove the four Phillips head screws on the left junction covers.
Set the junction covers and hardware aside. Left is from user's
standpoint.
Display
Board
Figure 17
Table of Contents
i Read All Instructions & Warnings
ii Important Safety Instructions
iv About This Manual
Important Voltage Information .
iv
FCC Compliance Information . iv
V Declaration of Conformity
vii Table of Contents
1 Safety
Warning Decals , . .
.. 1-1
Caution Decals . . . . . . . . . . . 1-2
2 Technical Specifications
Specifications
2-1
3 Preventative Maintenance
Regular
Maintenance Activities 3-1
Running Belt Maintenance.. 3-3
4 Troubleshooting
Test
Mode. . . . . . . . . . . . .. 4-1
LED Functions. . . . . . . . . .. 4-1
Key Functions . . . . . . . . . .. 4-2
Error Codes . . . . . . . . . . . . . 4-2
Speed Sensor Adjustments. 4-3
5 Removal &Replacement
Running
Deck . . . . . . . . . . .. 5-1
Running Belt . . . . . . . . . . . . . 5-5
Front Roller . . . . . . . . . . . . . . 5-5
Drive
Belt . . . . . . . . . . . . . . .. 5-5
Rear Roller 5-6
Drive Motor . . . . . . . . . . . .
.. 5-7
Motor
Brush , . . . .. 5-10
Elevation Motor 5-13
Lower Control
Board 5-15
Power Cables 5-16
Une Filter 5-17
Power Switch 5-17
Power Cord Inlet 5-18
Display
Board 5-18
Heart Rate Board 5-20
Lower Display
Board 5-21
Polar
Board 5-21
Upper Display Cable 5-22
Lower Display Cable 5-24
Display
CNeriays 5-25
6 Diagrams
Parts Ust . . . . . . . . . . . . . . .
6-1
Exploded View 6-3
600T Schematic 6-4
7 Customer Service
Contacting Service" . . . . . . . 7-1
Serial Number & Voltage. . . . 7-1
Retum Material Authorization
(RMA) 7-1
Damaged Parts. . . . . . . . . .. 7-2
8 Index 8-1
Page 5-23