cdacor oo. Installation Downdraft Models: Raised Instructions Vent ERV30, ERV36, ERV48 PRV30, PRV36, PRVAS Use these downdraft raised vents only with approved Dacor® appliances. See the installation instructions for the particular appliance model being installed to determine suitability. Part No. 65335 Rev.
of Contents important Safety INStrUCtiONS .......ccccececececeeesrerscneneneneneens important Information About Safety Instructions......00.... Safety Symbols and Labels ......ccccccccccccccceceeeeeeeeeeeeeees General Safety Precautions 0.0.0.0... ccccecccecccececeeeeeeeeeeeeeeeees Product SPOCiTICATIONS ©... cccecccececereecececeveueveceseseneneneneneneens Product DIMENSIONS ........cccccccccccccssessneeeneneceeeeeserereeeteeeeeees Installation SPecifiCAatiOn. .......
Important Safety Instructions Important Information About Safety Instructions * * Safety Symbols and Labels DANGER The Important Safety Instructions and warnings in these instructions are not meant to cover all possible problems and conditions that can occur. Use common sense and caution when installing, maintaining or operating this or any other appliance.
Important Safety Instructions General Safety Precautions To reduce the risk of fire, electric shock, serious injury or death when tions, including the following: using your appliance, follow basic safety precau- WARNING For general ventilating use only..Do not use to exhaust hazardous or.explosive materials and vapors. Use this raised vent only for-its intended purpose as outlined in the use and care manual. This appliance is not intended for commercial use.
Product Specifications Product Dimensions wot) ,? ~ (5.6 cm) é 7 5/16" (8mm)| : 21/8" thickstnener across t To . a ‘ 2 4/9" vent down % == \ \ fo ~ —»| | 115/16" \ (4.9.em) ‘FT oa oo ‘ (5 mm) \ Model Number p cap with >| [= 3/716" (6.4 cm) 9/16" ‘ ' (140m) ; a , 296" —| (6.50m) je See a aw “ - * unless otherwise stated ~ - oF om) , + Tolerances: t1/16” (41.6 mm) 23/16" > A- Top Cap Width 6 - Chassis Width ERV30 PRV30 30” (76.
Installation Specifications Electrical Specifications WARNING The electric outlet for-the raised vent should be installed only by-a licensed electrician. The raised vent is supplied with a 28” (71.1 cm) power cord with a three prong plug. Plug it directly into a three prong electrical outlet meeting the requirements below. Do not use an extension cord. The correct voltage, frequency and amperage must be supplied as specified below.
Installation Specifications Backsplash Backsplash 1 t t Countertop overhang Countertop Vertical 1 Vertical non-combustible surface rear wall non-combustible ‘ surface rear wall F 7 overhang \ Notches required for some rasied vent installations, see cooktop installation instructions Notches required for some raised vent installations, see range installation instructions See the cooktop installation instructions for exact countertop and cabinet dimensions Notches for self-rimming style insta
Installation Specifications Planning the Duct Work WARNING «To reduce the risk:of fire and to properly exhaust air, be sure to.duct air outside the house or building. Do not vent exhaust air into. spaces within walls or ceilings or into attics, crawl spaces or-garages. «Tape all duct joints securely to prevent combustion by-products, smoke. or odors from entering the home..Doing so will also improve. system efficiency. « TO-REDUCE THE RISK OF. FIRE, USE ONLY METAL DUCT WORK.
Installation Specifications On side exhaust installations, allow five inches of space on the side for the ADT2 exhaust transition plus additional space for the duct attached to it (X). K— | 5” ATD2 Make sure duct work does not interfere with floor joists or wall studs. X — ee _ With concrete slab construction, “box-in” the duct work and blower wiring to prevent collapsing or other damage when the wet concrete is poured.
Installation Instructions Installation Preparation z. Cut and remove the foil material inside the knock-out hole. If you fail to remove the foil, the vent will not work. Verify Package Contents 3.
Installation 5. Gently slide the vent into the rear of the countertop cut- out with the electrical access panel toward the front. Instructions Installing Blower and Ducts — ; 1. Install the remote or in-line blower according to the blower installation instructions. 2. Install the duct work according to the Installation Specifications section. Use sheet metal screws and duct tape to connect and seal all of the pieces. Support the duct weight as necessary to ensure sealed joints.
Installation Instructions Flectrical Installation 1. Run the wiring/conduit line used to supply power from the raised vent to the blower parallel to the duct work. WARNING * ELECTRIC SHOCK HAZARD 2. - Do not connect the raised vent power plug-to the electrical outlet until 3. Remove the cover from the raised vent electrical 4. Connect the wiring/conduit to the blower according to installation is complete. + access panel.
Installation Instructions REMP16 remote Connect wires/conduit according to remote blower installation instructions Raised vent blower “~~ \ Range See Raised Vent Electrical Access Panel on facing page ch Floor | DD LD Wiring/conduit from raised vent to remote blower Example of Installation with Bottom (Side View) Exhaust Range/Cooktop Installation install the range or cooktop according to its installation instructions.
Installation Instructions Verifying Proper Operation WARNING « Installation Checklist (| Are the anchor legs extended down to make contact with the floor and tightened into place? Are the anchor legs fastened to the floor? Is the unit level? CL] Is the duct work completely installed? Are all joints attached with sheet metal screws and wrapped with duct tape? (] Are both ends of the remote or in-line blower power cable connected (to the raised vent and to the blower itself)? (| Are the vent filters i
Wiring Diagram DOWN UMIT SWITCH UP UMIT SWITCH SNORKEL SWITCH COM p | COM | COM NO_NC NO_NC NC_NO) | RED —_ YS RED | BLUE | xs oO CHASSIS GROUND L | —d | Oo}; N L SPEED CONTROL mM ORNG 0 0 rT RELAY s oly x) — 46) © | WHT == REMOTE POT STUD COM A RED 0 NO L2 0 N2 0 Li 0 N1 GND GND 000000 Ll BLOWER OUTPUT | L POWER INPUT | L GROUND | BLK dacor 13
Cacor ee The Life of the Kitchen® Dacor e 600 Anton Bivd. Suite 1000 Costa Mesa, CA 92626 e Phone: (800) 793-0093 American Made e Fax: (626) 403-3130 « www.Dacor.
