Products Dishwasher Service Manual

Library Imaging System
Repeated dishwash_-
cycles
Timer does not advance
automatically
Dishwa"sher wii'i not fili
with water,
Incomplete water fill
Too much water fill
D'IshwasheI" Will not pum'p
out
Water siphons out..
Water leaks.
Poor w_sh ability
•Timer (contact's o_p'en or burnt)
=Motor (inoperative, check
resistances): .........
.Timer motor (stalled or open).
.Check timer for power to timer
motor.
=Timer shaft bindinl] or knob
interference to escutcheon.
•Water supply turns off
• Defective inlet valve,
-Check valve screen for
obstructions
.Defective float switch
=Timercontact_(openor burnt),
,Wtrin 9 (broken or burnt_,
• Low water pressure
• Clogged water inlet valve
screen,
=Timer advanced past sta_ of fill
cynic,
-Heavy water supply usage
elsewhere in home,
• Kinked or restricted fllf hose,
water inlet valve to till tunnel
=Water inlet fill valve defective
=Timer contacts (open or burnt)
=FI0at arm binding or out of
adjustment
=Possibility customeduser turned
timer past drain cycle.
,Drain pump is restricted
• Damaged impeller..
=Wiring or terminal (contacts
0_0_penorburntL,
.Drain hose loop to low.
=Drain line connected to a tioor
drain not vented.
.Spray arm not rotating or split
O Overcharge of water
,Tub seal (torn, worn or loose)
=Dishwasher door not sealing
properly.
aDishwasher is not level
• Overburden (wrong type of
detergent).
ahoy, clamp_ _oose_
• Heater element mounting nuts
loose
=Water seal leaking.
• ,.ring is not in position.
• Motor and pump assembly not
seated proper in tub liner bottom.
,: ,,J
_Spray arm not rotating.
• improper loading of dishes,
pans and other_.
-Detergent dispenser inoperative
m_nsuff_cient amount of detergent
Or the detergent Is old
=Damaged or the Impeller I_
broken.
• Detergent not dissolve
Replace timer
Replace timer
Replace timer
Replace timer
Repair or adjust
Turn water supply on.
Replace inlet valve_
Disassemble and clean screen.
Replace switch_
Replace timer,
Repair or replac e .
Minimum water pressure of
15P.S 1
Clean water inlet valve screen
Instruct customer/user to turn
tfmer dial to start indicator
m_r_,
Use dishwasher when water
usage is at a minimum.
Correct as needed
Replace water inlet fill valve
Replace timer.
Repair,adjustor replace.
Instruct customertuser
Clear restrictions
Replace drain pump,
Replace timer
Move to proper hetght..
Install vent air gap at counter
Check for proper rotation or
replace spray arm
Check and correct for proper
fill
Replace tub seal..
Adjust door latch assembly
andlor strike..
Level dishwasher properly
Instructs customer/user.
_')ghten aii clamps secure_.
Tighten the nut
Use a new water sear,
Adjust the ring or replace a
new.
Replace seat.
Clleck for proper rotation
instructs customeduser on
proper loading per owner's
guide..
Repair or replace dispenser
On proper amount of fresh
deter gent to use
Replace pump a_embly.
incoming water temperature of
t40"F is required to proper
dissolve detergent,