Flowlight Booster Pump Instruction Manual

Storage
Tank
R 1.1
Optional
Dry Run Protection
DSP-02526 for
1300/1400 Series,
DSP-02527 for
2500/2600 Series
Debris
Screen
www.dankoffsolar.com
Priming Port
if pump is above
water source
A STEADY BUZZING SOUND indicates
EXCESSIVE SUCTION.
An UNSTEADY BUZZING SOUND
indicates a LEAK IN THE SUCTION LINE.
See Page 14 for troubleshooting tips
PV
-
PV
+
Load
-
Load
+
Float
Switch
Float
Switch
Float
Switch
Weight
Dankoff LCB
30" Filter & Foot Valve DSP-11035
3 pack 30" Filters DSP-11036
Module wiring detail is for
illustration purposes ONLY.
Your array wiring will be
different. Consult with your
dealer for details
The Dankoff LCB
uses Reverse Action
Float switch logic:
Close on Rise
or
Pump Down
Air vent
Notes to Installer:
This pump pulls water in by suction. The inlet plumbing
must offer a very free flow, like a drain pipe in reverse.
The pump will be very noisy if intake is restricted or
blocked by air pockets or being undersized.
This pump tolerates NO solid debris.
A disposable cartridge filter is required at the intake.
NEVER run this pump without a filter.
Do not omit the intake screen.
After the first test run, check the screen
and remove any plumbing debris.
The manual contains important maintenance
information, and is the property of the pump owner.
Please give it to them when you are finished!
NOISE = CAVITATION = RAPID PUMP
WEAR
FIX THE PROBLEM!!!
Failure to install a fuse or breaker equal or less than the
motor's Max Amp rating will void your warranty.
See Page 3
See Page 14
See Page 2
See Page 6
Low voltage systems require larger wire than 115v.
See Dankoff Universal Wire Sizing Chart for assistance.
Note:
10" Inline Filter DSP-11033
may be used in place of
the 30" submerged filter.
Copyright Dankoff Solar 2004
©
2/2005
Solar SlowPump
EZ Install Diagram
Foot
Valve
Innovative Solar Solutions • 2725 Westinghouse Blvd Suite 100 • Charlotte, NC 28273 • [phone] • www.innovativesolar.com