MSDS

SDS Number: 00077348004 Revision Date: 5/15/2015
5. Fire-fighting Measures
UNUSUAL FIRE AND EXPLOSION HAZARDS: None known.
SPECIAL FIREFIGHTING PROCEDURES: Wear self-contained breathing apparatus pressure-demand (NIOSH approved or
equivalent) and full protective gear. Use water spray to cool exposed surfaces.
EXTINGUISHING MEDIA: Carbon Dioxide, Dry Chemical, Foam, Water Fog
6. Accidental Release Measures
ENVIRONMENTAL MEASURES: No Information
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Contain spilled material and remove with inert absorbent.
Dispose of contaminated absorbent, container and unused contents in accordance with local, state and federal regulations. Scrape
up dried material and place into containers. Use personal protective equipment as necessary. In case of spillage, absorb with inert
material and dispose of in accordance with applicable regulations.
7. Handling and Storage
HANDLING: KEEP OUT OF REACH OF CHILDREN!DO NOT TAKE INTERNALLY. Avoid breathing vapor and contact with eyes,
skin and clothing. Use only with adequate ventilation. Ensure fresh air entry during application and drying. Wash thoroughly after
handling. Contains isocyanates. See information supplied by the manufacturer. Persons allergic to isocyanates, and particularly
those suffering from asthma or other respiratory conditions, should not work with isocyanates.
STORAGE: Avoid excessive heat and freezing. Store away from caustics and oxidizers.
8. Exposure Controls/Personal Protection
Ingredients with Occupational Exposure Limits
Chemical Name ACGIH TLV-TWA ACGIH-TLV STEL OSHA PEL-TWA
OSHA PEL-CEILING
Polymeric diphenylmethane diisocyanate N.E. N.E. N.E. N.E.
Xylenes 100 ppm TWA 150 ppm STEL 100 ppm TWA, 435
mg/m3 TWA
N.E.
Carbon black 3 mg/m3 TWA
inhalable fraction
N.E. 3.5 mg/m3 TWA N.E.
Titanium dioxide 10 mg/m3 TWA N.E. 15 mg/m3 TWA
total dust
N.E.
Further Advice: MEL = Maximum Exposure Limit OES = Occupational Exposure Standard SUP = Supplier's Recommendation
Sk = Skin Sensitizer N.E. = Not Established
Personal Protection
RESPIRATORY PROTECTION: No personal respiratory protective equipment normally required. If concentrations
exceed the exposure limits specified, use of a NIOSH-approved supplied air respirator is recommended. Where the
protection factor is exceeded, use of a Self Contained Breathing Apparatus (SCBA) may be necessary. A respiratory
protection program that meets the OSHA 1910.134 and ANSI Z88.2 requirements must be followed whenever
workplace conditions warrant a respirator's use.
SKIN PROTECTION: Wear solvent impervious gloves.
EYE PROTECTION: Goggles or safety glasses with side shields.
Page 3 / 7