SDS

SDS Number: 00077348004 Revision Date: 1/31/2019
SAP Number:
8. Exposure Controls/Personal Protection
Ingredients with Occupational Exposure Limits
Chemical Name ACGIH TLV-TWA ACGIH-TLV STEL OSHA PEL-TWA
OSHA PEL-CEILING
Polymeric diphenylmethane diisocyanate N.E. N.E. N.E. N.E.
Xylenes 100 ppm TWA 150 ppm STEL 100 ppm TWA, 435
mg/m3 TWA
N.E.
Carbon black 3 mg/m3 TWA
inhalable particulate
matter
N.E. 3.5 mg/m3 TWA N.E.
Titanium dioxide 10 mg/m3 TWA N.E. 15 mg/m3 TWA
total dust
N.E.
Further Advice: MEL = Maximum Exposure Limit OES = Occupational Exposure Standard SUP = Supplier's Recommendation
Sk = Skin Sensitizer N.E. = Not Established
Personal Protection
RESPIRATORY PROTECTION: No personal respiratory protective equipment normally required. If concentrations
exceed the exposure limits specified, use of a NIOSH-approved supplied air respirator is recommended. Where the
protection factor is exceeded, use of a Self Contained Breathing Apparatus (SCBA) may be necessary. A respiratory
protection program that meets the OSHA 1910.134 and ANSI Z88.2 requirements must be followed whenever workplace
conditions warrant a respirator's use.
SKIN PROTECTION: Wear solvent impervious gloves.
EYE PROTECTION: Goggles or safety glasses with side shields.
OTHER PROTECTIVE EQUIPMENT: Provide eyewash and solvent impervious apron if body contact may occur.
HYGIENIC PRACTICES: Wash hands before breaks and at the end of workday. Remove and wash contaminated
clothing before re-use.
9. Physical and Chemical Properties
Appearance: White to Off-White Physical State: Paste
Odor: Slight Odor Threshold: Not Established
Density, g/cm3: 1.40 - 1.40 pH: Not Applicable
Freeze Point, °C: Not Established Viscosity (mPa.s): Not Established
Solubility in Water: No Information Partition Coeff., n-octanol/water: Not Established
Decomposition Temperature, °C: Not Established Explosive Limits, %: N.E. - N.E.
Boiling Range, °C: 100 - 100 Auto-Ignition Temperature, °C Not Established
Minimum Flash Point, °C: 100 Vapor Pressure, mmHg: Not Established
Evaporation Rate: Slower Than n-Butyl Acetate Flash Method: Seta Closed Cup
Vapor Density: Heavier Than Air
Flammability, NFPA: Non-Flammable
Combustibility: Does not support combustion
(See "Other information" Section for abbreviation legend)
(If product is an aerosol, the flash point stated above is that of the propellant.)
Page 3 / 6