SDS

SDS Number: 4900004 Revision Date: 1/1/0001
SAP Number:
9. Physical and Chemical Properties
Appearance: Orange Physical State: Aerosol
Odor: Slight Odor Threshold: Not Established
Density, g/cm3: 1.35 - 1.35 pH: Between 7.0 and 12.0
Freeze Point, °C: Not Established Viscosity (mPa.s): Not Aplicable
Solubility in Water: Not Established Partition Coeff., n-octanol/water: Not Established
Decomposition Temperature, °C: Not Established Explosive Limits, %: N.E. - N.E.
Boiling Range, °C: N.A. - N.A. Auto-Ignition Temperature, °C Not Established
Flash Point, °C: N.A. Vapor Pressure, mmHg: Not Established
Evaporation Rate: Faster Than n-Butyl Acetate Flash Method: Not Applicable
Vapor Density: Heavier Than Air
Flammability, NFPA: Aerosol Level I
Combustible Dust: Does not support combustion
(See "Other information" Section for abbreviation legend)
(If product is an aerosol, the flash point stated above is that of the propellant.)
10. Stability and Reactivity
STABILITY: Stable under recommended storage conditions.
CONDITIONS TO AVOID: Do not burn or use a cutting torch on the empty container. Excessive heat or flames, incompatible
substances. Excessive heat and freezing.
INCOMPATIBILITY: Incompatible with strong bases and oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: Above 1450 degree C: SO2 and CaO.
11. Toxicological Information
EFFECT OF OVEREXPOSURE - INHALATION: Dust from dry sanding may cause eye, skin, nose, throat and respiratory tract
irritation.
EFFECT OF OVEREXPOSURE - SKIN CONTACT: Under normal use conditions, this product is not expected to cause adverse
health effects. Prolonged or repeated contact with skin may cause mild irritation.
EFFECT OF OVEREXPOSURE - EYE CONTACT: Under normal use conditions, this product is not expected to cause adverse
health effects. Direct eye contact may cause irritation.
EFFECT OF OVEREXPOSURE - INGESTION: Under normal use conditions, this product is not expected to cause adverse health
effects. Single dose oral toxicity is very low. Amounts ingested incidental to industrial handling are not likely to cause injury;
however, ingestion of large amounts may cause injury. Ingestion may result in obstruction when material hardens.
CARCINOGENICITY: No Information
EFFECT OF OVEREXPOSURE - CHRONIC HAZARDS: The International Agency for Research on Cancer (IARC) has determined
that crystalline silica in the form of quartz or cristobalite that is inhaled from occupational sources is carcinogenic to humans (Group
1- carcinogenic to humans). Refer to IARC Monograph 68, Silica, Some Silicates and Organic Fibres (published in June 1997) in
conjunction with the use of these materials. The National Toxicology Program (NTP) classifies respirable crystalline silica as "known
to be a human carcinogen". Refer to the 9th Report on Carcinogens (2000). The American Conference of Governmental Industrial
Hygienists (ACGIH) classifies crystalline silica, quartz, as a suspected human carcinogen (Group A2). Breathing dust containing
respirable crystalline silica may not cause noticeable injury or illness even though permanent lung damage may be occurring.
Inhalation of dust may have the following serious chronic health effects: Excessive inhalation of respirable dust can cause
pneumoconiosis, a respiratory disease, which can result in delayed, progressive, disabling and sometimes fatal lung injury.
Symptoms include cough, shortness of breath, wheezing, non-specific chest illness and reduced pulmonary function. Smoking
exacerbates this disease. Individuals with pneumoconiosis are predisposed to develop tuberculosis. There is some evidence that
breathing respirable crystalline silica or the disease silicosis is associated with an increased incidence of significant disease
endpoints such as scleroderma (an immune system disorder manifested by fibrosis of the lungs, skin and other internal organs) and
kidney disease. Prolonged or repeated inhalation of dust may cause lung damage. Constituents of this product include crystalline
silica which ,if inhalable, may cause silicosis, a form of progressive pulmonary fibrosis. Inhalable crystalline silica is listed by IARC
as a group I carcinogen (lung) based on sufficient evidence in occupationally exposed humans and sufficient evidence in animals.
Crystalline silica is also listed by the NTP as a known human carcinogen. Constituents may also contain asbestiform or non-
asbestiform tremolite or other silicates as impurities, and above de minimus exposure to these impurities in inhalable form may be
carcinogenic or cause other serious lung problems.
PRIMARY ROUTE(S) OF ENTRY: Skin Contact, Inhalation, Eye Contact
Page 4 / 7