EcoPure ® Cartridge Filter INSTALLATION & OPERATING INSTRUCTIONS 50sqft 75sqft 100sqft 150sqft IMPORTANT: PLEASE READ THIS DOCUMENT CAREFULLY. Please pass these instructions on to the operator of this equipment. davey.com.
INTRODUCTION The installation of this product should be carried out by a person knowledgeable in swimming pool plumbing requirements following the Installation Instructions provided in this manual. Please pass these instructions on to the owner of this equipment. YOUR MONARCH SERIES CARTRIDGE FILTER Congratulations on your purchase of a quality product from the Monarch Series range of Pool and Spa Equipment.
INSTALLATION & OPERATING INSTRUCTIONS LOCATION The filter should be placed in its permanent location, preferably as close to the pool as practicable. Position the filter tank and pump on a level concrete slab or similar base. Allow sufficient space around the filter for routine maintenance and provide for adequate ventilation and drainage. Place the pump in position on the slab and locate the filter alongside with the appropriate pump inlet connection oriented towards the pump.
1. PUMP TO THE FILTER Monarch Series Cartridge Filters are equipped with two inlet ports marked ‘INLET’. Select the inlet port most suitable for the installation and plug the other inlet port with the blanking cap provided. Using the barrel unions provided, connect the pool pump delivery piping to the selected inlet port. Tighten by hand only. Ensure the oring on the fitting is clean, lubricated with oring lubricant and in the correct position. 2.
CARTRIDGE CLEANING PROCEDURE When the filter gauge reading is 50 - 70kPa above the clean filter gauge reading, cleaning the element cartridge is required. To perform the cleaning procedure : 1. Switch off the pump. 2. Close isolating valves on suction and discharge lines where fitted. 3. Open the air bleed valve on the filter lid, unscrew the lock ring and remove the filter lid. 4. Lift the element out. 5.
FILTER CARE The Monarch Series Cartridge Filter is the heart of the pool equipment installation. Proper care and maintenance will add many years of service and enjoyment to your pool. Keep the exterior of the filter clean using a mild detergent and water. TROUBLE SHOOTING Reduced flow of water to the pool generally indicates the filter is ready to be cleaned. Check the filter pressure gauge. (See section on ‘Filter Operation’).
NOTE: When making any enquiries about your Davey Filtration Equipment, be certain to quote the Model Number from the nameplate on the equipment. To avoid explosion and possible severe or fatal injury, filter pressure must not exceed 280kPa. Do not test filter with compressed air. Check that all clamps and fasteners are in good condition and are firmly secured before pressurising system. Never adjust clamps or fasteners while filter is pressurised. DANGER - Hazardous suction.
Routine Maintenance tasks – to maximise the life of your pool equipment & personal safety, use this checklist once a week. Turn pump off first. a. Make sure that any pressure gauges are in working condition and the operating pressure is within limits as specified on the product. b. Make sure that each suction inlet, and main drain has a cover that is securely attached and in safe working condition. c. Make sure that all skimmer covers are securely attached and in safe working condition.
SPECIFICATIONS D = Clearance to remove cartridge TECHNICAL DATA Max Max Filtration Flow Max Operating Area Filtration Rate 4 Hour 6 Hour Operating Temp (sq metres) Area Model (lpm) Turnover Turnover Pressure (kPa) (°C) (sq feet) Q2201MN 230 55,000 83,000 280 45 4.75 50 Q2202MN 325 78,000 117,000 280 45 7.0 75 Q2203MN 400 96,000 144,000 280 45 9.5 100 Q2204MN 490 117,000 176,000 280 45 14.
Notes • Page 10 •
Notes • Page 11 •
Davey® Repair or Replacement Guarantee In the unlikely event in Australia or New Zealand that this Davey product develops any malfunction within warranty periods beginning from the date of original purchase due to faulty materials or manufacture, Davey will at our option repair or replace it for you free of charge, subject to the conditions below.
