User Manual

ManualsBrandsDaystar ManualsCarKT09124BK

www.DaystarWeb.com

Tech Support Contact Info

Tech@DaystarWeb.com

Phone: 623.907.0081

Fax: 623.907.0088

841 South 71

Avenue

Phoenix, AZ 85043

Instruction Sheet P1 1131

2006 Daystar Products International Inc.

1 of 4 pages

FJ Cruiser Easy install front and rear spacer lift.

Kit number KT09124

Summary of content (4 pages)

PAGE 1
www.DaystarWeb.com Tech Support Contact Info Tech@DaystarWeb.com Phone: 623.907.0081 Fax: 623.907.0088 841 South 71st Avenue Phoenix, AZ 85043 FJ Cruiser Easy install front and rear spacer lift. Kit number KT09124 Instruction Sheet P11131 2006 Daystar Products International Inc.
PAGE 2
Installation Steps 1. Read all instructions and check bill of materials and tools before beginning. 2. Disconnect the negative battery cable. 3. Place the vehicle on a clean and level surface. Set the parking brake and place wheel chocks behind the rear wheels. Jack up the front of the vehicle by the frame with a floor jack and support vehicle at the frame rails with approved jack stands. NEVER WORK UNDER AN UNSUPPORTED VEHICLE. 4.
PAGE 3
Installation Steps 12. Remove the lower strut bolt and nut ( 19mm) . 13. Remove the strut from the vehicle. 14. Install the stud extenders and spacer on the top of the strut plate. 15. Reinstall the strut into the vehicle and tighten the upper strut nuts. You will have to push up on the upper a-arm to get the strut back in. 16. Reinstall the suspension working in reverse order. 17. Recheck all bolts after 500 miles. 18. Daystar Recommends that you have your wheel alignment checked.
PAGE 4
Rear instructions sheet. Rear Bill of Materials Part No Description Qty M03726 Spacer 2 1. Jack up the rear end and place jack stands under the frame allowing the rear suspension to move up and down freely. 2. Disconnect the sway bar and rear shocks at the axle and track bar so the axel will droop down. 3. Remove the coil spring , isolator and bump-stop. 4. Put the stop bump-stop on the spacer and install the spacer , bump-stop and spring. 5.