Installation Guide 48" Grill, LP Gas

SAFETY AND WARNINGS

IMPORTANT SAFETY INSTRUCTIONS!

y Be sure all grill controls are turned off and the grill is cool before using any type of aerosol cleaner

on or around the grill. The chemical that produces the spraying action could, in the presence of heat,

ignite or cause metal parts to corrode.

y Never grill without the drip pan and grease tray in place and pushed all the way to the back of the

grill. Without it hot grease could leak downward and produce a fire or explosion hazard.

y Do not place griddle plates (some models only) side by side on the grill or on top of the Infrared

Hybrid Burner.

y Do not use the Infrared Hybrid Burner on BGB-36” or BGB-48” models. Use on BH1-36” & BH1-48”

models only.

y If a cart unit is stored indoors, ensure that it is cool, fold the side shelf down, then push the grill,

never pull. Never push or pull on the side shelves. If LP, the cylinder must be unhooked and the LP

cylinder stored outside in a well ventilated area, out of reach of children.

y Never use the grill in a windy area.

y Do not locate, store or operate the grill on an inclined plane. Make sure you lock the castor wheels

before operating the grill.

y Do not use charcoal or lighter fluid in the outdoor grill.

y Keep any electrical supply cord, or the rotisserie motor cord away from the heated areas of the grill

and water (pools, fountains, puddles).

y Never use a dented or rusty LP tank. Keep the ventilation openings of the cylinder enclosure free and

clear from debris.

y Do not move the appliance during its use.

y This unit is for outdoor use only. Do not operate in enclosed areas. This could result in carbon

monoxide build-up which would result in injury or death.

y When using a grill, be sure that all parts of the unit are firmly in place and that the grill is stable

(can’t be tipped over).

y To put out flare-ups, adjust the controls to lower the temperature

y Never attach or disconnect an LP cylinder, or move or alter gas fittings when the grill is in operation

or is hot.

y Clean and perform general maintenance on the grill twice a year. Watch for corrosion, cracks,

or insect activity. Check the regulator, hoses, burner ports, air shutter, and venturi/valve section

carefully. Always turn off gas at the source (tank or supply line) prior to inspecting parts.

y If you own or use a spare tank, or have a disconnected tank, you should NEVER store it near or under

the grill/cart unit or heat box, or near any other ignition or heat source. A metallic sticker with this

warning is provided with the grill to remind you, your family and all others who may use your BBQ

grill of these safety precautions. Install this sticker close to your barbeque grill.

Sticker