Installation Instructions for Del Rey Heater Remote Control Kit

ManualsBrandsDCS ManualsElectric Heater-DRH48N

DEL REY HEATER REMOTE CONTROL KIT

INSTALLATION INSTRUCTIONS

IMPORTANT!

Read all instructions before you begin. Do not jump ahead or skip any step.

CAUTION!

Some parts may have sharp edges; care must be taken when handling the various components

to avoid injury. Please read safety information provided in these instructions before beginning

assembly. Be sure to have a qualified technician install and ground this appliance before using.

CONTENTS INCLUDED:

The package contains a weather-proof receiver assembly, wire nuts, a transmitter remote control and

installation sheet (Fig. 01 & 02).

Control

Button

Activation

light

Fig. 02

Fig. 03

Fig. 01

Contents Qty.

TOOLS REQUIRED:

Receiver Assembly

Wire Nuts

Transmitter

Transmitter Receiver,

inside Receiver Assembly

Instruction

Eye Goggles

Work Gloves

Power Screwdriver or

Variable Speed Drill with

Phillips -tip #2 Attachment

Summary of content (8 pages)

PAGE 1
DEL REY HEATER REMOTE CONTROL KIT INSTALLATION INSTRUCTIONS IMPORTANT! Read all instructions before you begin. Do not jump ahead or skip any step. CAUTION! Some parts may have sharp edges; care must be taken when handling the various components to avoid injury. Please read safety information provided in these instructions before beginning assembly. Be sure to have a qualified technician install and ground this appliance before using.
PAGE 2
FCC This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: 1. This device may not cause harmful interference. 2. This device must accept any interference received, including interference that may cause undesired operation. WARNING Changes or modifications to this unit not expressly approved by DCS by Fisher & Paykel could void the user’s authority to operate the equipment.
PAGE 3
EXISTING TRANSFORMER CONFIGURATION N L G RECEPTACLE 24 VAC Input Weatherproof protective enclosure REMOTE SENSOR GROUND CHASSIS Transformer 9HX9 APPLIANCE CONTROL 24 VAC 115 VAC Power REMOTE CONTROLLED CONNECTION 110 VAC 24 VAC GROUND CHASSIS 24 VAC Input STEP DOWN TRANSFORMER Existing transformer is replaced with the receiver assembly L N G 24 VAC 115 VAC G 18 CA AWG INPUT (110 VAC MIN. 60 Hz, 10 Amp) Power 18 AWG OUTPUT (24 VAC MIN.) TO HEATER Fig. 06 Fig.
PAGE 4
LOCATION Do not locate this unit or any electrical supply line directly over the heater. Electrical short or fire may occur due to overheating. Follow the diagram below for appropriate zones for the installation of this unit (Fig. 08). WARNING The unit must be mounted outside the shaded areas shown in the diagram below (Fig. 08). The remote control box must be installed in a location such that it is accessible for servicing.
PAGE 5
TROUBLESHOOTING (CONTINUED): Manual shutdown (if it becomes necessary to turn off heater without using the remote): 1. Switch the power to “OFF” or, 2. Open the circuit breaker that supplies power to the heater. 3. Wait for flame to extinguish completely before restoring power to the circuit again. Note: It will be necessary to use the remote to start the heater again after a manual shutdown. HOW TO OBTAIN SERVICE: For warranty service, contact DCS Customer Care Center at (888) 281-5698.
PAGE 6
LIMITED WARRANTY When you purchase a new DCS remote control by Fisher & Paykel, you automatically receive a One Year Limited Warranty covering parts and labor for the entire product, and a Five Year Limited Warranty on all stainless steel components for servicing within the 48 mainland United States, Hawaii, Washington D.C. and Canada. In Alaska, the Limited Warranty is the same except that you must pay to ship the Product to the service shop or for the service technician’s travel to your home.
PAGE 7
C. Defects to the Product caused by accident, neglect, misuse, fire, flood or Act of God. D. The cost of repairs carried out by non-authorized repairers or the cost of correcting such unauthorized repairs. E. Travel Fees and associated charges incurred when the product is installed in a location with limited or restricted access (i.e. airplane flights, ferry charges, isolated geographic areas). F. Normal recommended maintenance as set forth in the Product’s User Guide.
PAGE 8
Fisher & Paykel Appliances, Inc. 5900 Skylab Road, Huntington Beach, CA 92647 Customer Care: 888.281.5698 • Fax: 714.372.7003 www.dcsappliances.