EN Solar domestic hot water calorifier 200 SSL User Guide M002327-B 300028225-001-02
Contents 1 Introduction ................................................................................................4 1.1 Symbols used .......................................................4 1.1.1 1.1.2 1.2 Abbreviations ........................................................4 1.3 General ..................................................................5 1.3.1 1.3.2 1.3.3 1.4 3 Certifications ...........................................................
Contents 3.3 4 5 6 7 Operating the appliance ..........................................................................11 4.1 Commissioning procedure ................................11 4.2 Antifreeze protection ..........................................11 4.3 Shutting down the solar control system ..........11 Checking and maintenance .....................................................................13 5.1 General instructions ...........................................13 5.
3 01/08/2013 - 300028225-001-02
1. Introduction 200 SSL 1 Introduction 1.1 Symbols used 1.1.1. Symbols used in the manual In these instructions, various danger levels are employed to draw the user’s attention to particular information. In so doing, we wish to safeguard the user’s safety, obviate hazards and guarantee correct operation of the appliance. DANGER Risk of a dangerous situation causing serious physical injury. WARNING Risk of a dangerous situation causing slight physical injury. CAUTION Risk of material damage.
200 SSL 1. Introduction 4 SCU: Secondary Control Unit - control panel PCB 1.3 General 1.3.1. Manufacturer’s liability Our products are manufactured in compliance with the requirements of the various applicable European Directives. They are therefore delivered with [ marking and all relevant documentation. In the interest of customers, we are continuously endeavouring to make improvements in product quality.
200 SSL 1. Introduction This appliance is not intended to be used by persons (including children) whose physcial, sensory or mental capacity is impaired or persons with no experience or knowledge, unless they have the benefit, through the intermediary of a person responsible for their safety, of supervision or prior instructions regarding use of the appliance. Care should be taken to ensure that children do not play with the appliance.
2. Safety instructions and recommendations 200 SSL 2 Safety instructions and recommendations 2.1 Safety instructions CAUTION Before any work, switch off the mains supply to the appliance. 2.2 Recommendations Have the installation regularly serviced to guarantee that it operates correctly over time. It is essential to check the magnesium anode in the DHW tank and the installation and heat transporting fluid pressure every two years.
200 SSL 3. Description 3 Description 3.
3. Description 200 SSL DHW tank 200SSL Maximum operating temperature °C Maximum operating pressure bar (MPa) 10 (1.0) Water content l Top up volume l 90 Solar volume Weight l 110 Shipping weight (Foam coated domestic hot water tank) kg 95 200 112 Gas fired floor-standing condensing boiler (1) Performances related to the boiler type 17/29 kW Power exchanged 25 kW kW 24 24 l/h 590 590 l/min 18 18 Draw-off capacity(3) l/10 mm 180 180 Qp: Primary flow rate m3/h 1.1 1.
200 SSL CESI System 3.
4. Operating the appliance 200 SSL 4 Operating the appliance 4.1 Commissioning procedure CAUTION Initial commissioning must be done by a qualified professional. CAUTION During the heating process, a certain amount of water may flow through the valve or safety unit, this is caused by water expansion. This phenomenon is completely normal and must in no event be hindered. Once the DHW tank has been connected to the mains, the unit is managed from the boiler control panel.
200 SSL 4. Operating the appliance The system is designed in such a way that no special precautions are necessary during long periods of absence in summer. The solar control system protects the installation from overheating.
5. Checking and maintenance 200 SSL 5 Checking and maintenance 5.1 General instructions CAUTION 4 4 5.2 Maintenance operations must be done by a qualified engineer. Only original spare parts must be used. Safety valve or safety unit (Domestic hot water circuit) The valve or safety assembly must be operated at least once a month in order to ensure that it is operating correctly and to prevent possible overpressure which would damage the DHW tank.
200 SSL 5.6 5. Checking and maintenance solar regulator The solar control system is governed by the boiler control system. All parameters and settings on the solar control system are managed from the boiler control panel. ¼Refer to the installation and maintenance instructions of the boiler. 5.7 Maintenance of the thermostatic mixing valve The thermostatic mixer tap does not require any particular maintenance.
200 SSL 6. Warranty 6 Warranty 6.1 General You have just purchased one of our appliances and we thank you for the trust you have placed in our products. Please note that your appliance will provide good service for a longer period of time if it is regularly checked and maintained. Your installer and our customer support network are at your disposal at all times. 6.
200 SSL 6. Warranty The warranty is limited to the exchange or repair of such parts as have been recognised to be faulty by our technical department and does not cover labour, travel and carriage costs. The warranty shall not apply to the replacement or repair of parts damaged by normal wear and tear, negligence, repairs by unqualified parties, faulty or insufficient monitoring and maintenance, faulty power supply or the use of unsuitable fuel. Sub-assemblies such as motors, pumps, electric valves etc.
7. NF CESI data sheet 200 SSL 7 NF CESI data sheet 7.
200 SSL 01/08/2013 - 300028225-001-02 7.
© Copyright All technical and technological information contained in these technical instructions, as well as any drawings and technical descriptions supplied, remain our property and shall not be multiplied without our prior consent in writing.