Compact Refrigerators & Freezers Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately.
Compact Refrigerators and Freezers Service and Installation Manual Important Warning And Safety Information WARNING Read This Manual Thoroughly Before Operating, Installing, Or Performing Maintenance On The Equipment. WARNING Failure To Follow Instructions In This Manual Can Cause Property Damage, Injury Or Death. WARNING Do Not Store Or Use Gasoline Or Other Flammable Vapors Or Liquids In The Vicinity Of This Or Any Other Appliance.
Compact Refrigerators and Freezers Service and Installation Manual Contents Receiving & Inspecting Equipment.................................................. 3 Serial Number Location................................................................... 4 Warranty Information....................................................................... 4 Regulatory Certifications.................................................................. 4 Specifications........................................................
Compact Refrigerators and Freezers Service and Installation Manual Serial Number Location The serial number on 400 series compact refrigerators and freezers is printed on the right side of the interior back wall. The serial tag on 4000 series compact refrigerators and freezers is located either on the left upper sidewall inside the cabinet or under the top nosing directly above the door when the door is in the closed position (right hand door when there are two doors).
Compact Refrigerators and Freezers Service and Installation Manual Specifications Work Top Refrigerator Bases With Stainless Steel Top & Backsplash Model L D H Volume Ft.3 Shelves Ft.2 H.P. Refg. Charge Amp NEMA Plug Ship Weight 402 27” 28.5” 39.5” (68.6cm) (72.4cm) (100.3cm) 5.7 4.6 1/5 7.0 4.0 5-15P 176lbs (80kg) ST4048 48” 28.5” 39.5” (121.9cm) (72.4cm) (100.3cm) 10.80 8.0 1/5 7.0 4.0 5-15P 234lbs (106kg) Volume Ft.3 Shelves Ft.2 H.P. Refg.
Compact Refrigerators and Freezers Service and Installation Manual Installation Location Units represented in this manual are intended for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. Reinforce the floor as necessary to provide for maximum loading. For the most efficient refrigeration, be sure to provide good air circulation inside and out. Inside cabinet: Do not pack refrigerator so full that air cannot circulate.
Compact Refrigerators and Freezers Service and Installation Manual Caster Or Leg Installation - 400 & 4000 Series 1. Carefully place the unit on its back (see illustration at right). Plate Casters W/Locks 2. Located at each caster mounting location are 4 Phillips head screws, for a total of 16 screws. Remove them. 3. Place a locking plate caster or leg over one of the front holes, matching the 4 mounting holes to the pre-drilled holes in the underside of the unit.
Compact Refrigerators and Freezers Service and Installation Manual Refrigerator Temperature Control Operation After the unit is connected to power it will automatically begin operating. With the doors closed, the temperature of the cabinet should reach 36°F to 40°F (2°C to 4°C) on refrigerators in about one hour. A thermostat located in the evaporator housing on interior rear of the unit, controls the temperature in the box.
Compact Refrigerators and Freezers Service and Installation Manual Freezer Models 403 & 407 Temperature Control Operation Freezer Automatic Defrost After the unit is connected to power it will automatically begin operating. With the doors closed, the temperature of the cabinet should reach 0°F (-18°C) on freezers in about one hour. Continuous opening and closing of the doors will hamper the unit’s ability to maintain optimum temperature.
Compact Refrigerators and Freezers Service and Installation Manual Maintenance The thermostat must be turned to OFF and the unit disconnected from the power source whenever performing service, maintenance functions or cleaning the refrigerated area. Refrigerators and Freezers The interior and exterior can be cleaned using soap and warm water. If this isn’t sufficient, try ammonia and water or a nonabrasive liquid cleaner.
Compact Refrigerators and Freezers Service and Installation Manual Maintenance, continued them to become brittle and prevent proper seals. Also, never use sharp tools or knives to scrape or clean the gasket which could possibly tear the gasket and rip the bellows. Gaskets can easily be replaced and do not require the use of tools or authorized service persons. The gaskets are “Dart” style and can be pulled out of the grove in the door and new gaskets can be “pressed” back into place.
Compact Refrigerators and Freezers Service and Installation Manual Refrigerator Wiring Diagram - 400 and 4000 Series 115V/60Hz/1Ø L1 Black G N NEMA 5-15P Supply Cord & Plug Furnished White Evaporator Fan Temperature Control Condensing Unit Refrigerator Replacement Parts List 402/406/406CA Part # 3234025 3234024 3234160 3234161 3234791 000-B3I-0031 000-B3I-0030 0074057 3526997 3516446 2194787 158-ATA-0050 149-AWM-0040 3516275 3516172 2162691 1702623 3516116 3516172 2162691 3516321 3237569 3237563
Compact Refrigerators and Freezers Service and Installation Manual Freezer Wiring Diagrams - 400 and 4100 Series 400 Series 400 Series 115V/60Hz/1Ø L1 G Black 4100 Series NEMA 5-15P Supply Cord & Plug Furnished N 115V/60Hz/1Ø L1 G Black White NEMA 5-15P Supply Cord & Plug Furnished N White Mullion Heater (4148 Only) Black TM Defrost Timer Defrost Limit Defrost Limit Defrost Heater Defrost Heater Evaporator Fan Evaporator Fan Defrost Timer Defrost Timer Temperature Control Condensing
Compact Refrigerators and Freezers Service and Installation Manual Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. • A maximum of 1-hour is allowed to diagnose a defective component. • A maximum of 1-hour is allowed for retrieval of parts not in stock. • A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed.
Compact Refrigerators and Freezers Service and Installation Manual Notes For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.
Delfield ™ ® Covington, TN Mt. Pleasant, MI Thank you for choosing Delfield! Help is a phone call away. Help our team of professional, courteous customer service reps by having your model number and serial number available at the time of your call (800) 733-8829. Model:________________________ S/N: _______________________ Installation Date:________________ For a list of Delfield’s authorized parts depots, visit our website at www.delfield.com Register your Delfield warranty online. Go to www.
