Delfield ™ ® F5 and F15 Series Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately. See page 2.
F5 & F15 Series Service and Installation Manual Contents Serial Number Location.....................................................................2 Receiving & Inspecting Equipment....................................................2 Specifications F5 Series....................................................................................3 F15 Series..................................................................................4 Installation F5 Series.................................................
F5 & F15 Series Service and Installation Manual F5 Series Specifications 24” (61cm) Deep Remote Drop-In Refrigerated Display Cases MODEL L D VOLTS/ HERTZ/ PHASE H AMPS CABINET LOAD BTU/ HOUR EVAPORATOR DISPLAY CAPACITY BTU °TD TEMP F5MR48N 48" (121.9cm) 24" (61.0cm) 42" (106.7cm) 115/60/1 4.0 1215 150 20° 15° F5SR48N 48" (121.9cm) 24" (61.0cm) 42" (106.7cm) 115/60/1 4.0 1867 150 20° 15° F5PR48N 48" (121.9cm) 24" (61.0cm) 42" (106.7cm) 115/60/1 4.
F5 & F15 Series Service and Installation Manual F15 Series Specifications 24” (61cm) Deep Remote Serview Refrigerated Display Cases AMPS CABINET LOAD BTU/ HOUR EVAPORATOR DISPLAY CAPACITY EVAPORATOR BASE CAPACITY BTU °TD TEMP BTU °TD TEMP MODEL L D H VOLTS/ HERTZ/ PHASE F15MR48N 48" (121.9cm) 31.5" (80.0cm) 78" (198.1cm) 115/60/1 4.0 1644 200 23° 12° 120 30° 5° F15SR48N 48" (121.9cm) 33.38" (84.8cm) 78" (198.1cm) 115/60/1 4.
F5 & F15 Series Service and Installation Manual Installation: Self-Contained F5 Series Location Units represented in this manual are for indoor use only. All self-contained units were tested at the factory to assure proper operation. The unit should not be installed directly next to high heat generating equipment (ranges, griddles, etc.). Be sure the location chosen has a counter strong enough to support the total weight of the cabinet and contents.
F5 & F15 Series Service and Installation Manual Installation: Self-Contained F15 Series Location Plumbing Units represented in this manual are for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. A fully loaded model may weigh as much as 3,000 pounds! Reinforce the floor as necessary to provide for maximum loading. For the most efficient refrigeration, be sure to provide good air circulation inside and out.
F5 & F15 Series Service and Installation Manual Shelf Installation Display Lock Operation Display cases come with four epoxy coated wire shelves that are adjustable in 3-3/4" increments. Maximum weight for shelves is 75 pounds. Overloading shelves can damage equipment or cause bodily injury. At the factory, the keys are taped to the display case. Follow the directions below to lock and unlock the display case. To lock: Line up key ridge with red dot. Insert key and rotate one-half turn.
F5 & F15 Series Service and Installation Manual Display Temperature Control Settings The display temperature control is located on the evaporator assembly on the ceiling of the display case. It is field adjustable and does not require a service agent. The factory setting is 2.5. Set toward 1 for higher temperatures and toward 7 for lower temperatures. Please make small incremental adjustments if a temperature adjustment is necessary.
F5 & F15 Series Service and Installation Manual Maintenance Door Gasket Maintenance Door gaskets require regular cleaning to prevent mold and mildew build up and also to retain the elasticity of the gasket. Gasket cleaning can be done with the use of warm soapy water. Avoid full strength cleaning products on gaskets as this can cause them to become brittle and crack. Never use sharp tools or knives to scrape or clean the gasket.
F5 & F15 Series Service and Installation Manual Condenser Air Flow: F5 F5 units are designed to be operated with two supplied louvered panels for proper air flow. Failure to provide the proper air flow will void the warranty. Louver cut-outs are 22" by 11" (55.9cm by 27.9cm) typical. Cut-outs are to begin a maximum of 4.00" (10.2cm) from the counter-top. Proper installation must provide for air flow to and from the condensing unit. Install as shown below.
F5 & F15 Series Service and Installation Manual Pike Sliding Door All Delfield F5 Series and F15 Series display cases feature a Pike® sliding door assembly. A typical Pike sliding door assembly is shown in the illustration at right. Maintenance Frequent, regular cleaning with a mild soap and water solution will keep the tracks free of foreign matter and will insure many years of service. The glass may be cleaned with one of the many commercial glass cleaners currently available.
F5 & F15 Series Service and Installation Manual Condensing Unit Assembly 1/2 H.P. F5 48" Models 7 6 5 1 2 4 3 Key Delfield Part # Description - 000-BN5-0035 Condensing Unit Assembly 1 026-C58-0031 Shroud, 1/2 HP condenser coil 2 3516554 Blade, fan 9.
F5 & F15 Series Service and Installation Manual Fluorescent Light Fixture 7 1 Key Part# Description - 000-406-0039 Complete assembly, 60" 000-406-0037 Complete assembly, 36” 000-406-0038 Complete assembly, 48” 1 313-146-0032 cap, end, top mtg, pigtail, -rem. 2 313-146-0033 cap, end, top mtg, blank, -rem. 3 376-A0M-0055 diffuser, fluor. light, 36” 376-A0M-0056 diffuser, fluor. light, 48" 376-A0M-0057 diffuser, fluor.
F5 & F15 Series Service and Installation Manual F15 Base Evaporator Assembly Key 1 2 3 4 5 6 7 8 - Part Number 000-248-0030 2160024 2160023 3516095 030-232-0003 3516273 030-233-0001 075-231-0033 030-234-0003 2184317 2195551 Description Coil Assembly, R404A, Ref Guard, fan, 4.
F5 & F15 Series Service and Installation Manual Miscellaneous Replacement Parts Part Number Description Part Number Display Cases Description Mirror Glass 3516172 Blade, fan, Lexan, clear 3455418 Mirror, glass, top, 72” 031-264-0000 Bracket, fan motor, blower coil Shelving & Misc. Parts — Serview Bases 3516173 Fan Guard 3234290 Shelf support, plastic, plug 1” 3516090 Coil, evaporator, 48” 3977984 Shelf, wire, 19” door, 14.38 x 25.
F5 & F15 Series Service and Installation Manual Wiring Diagram: Self-Contained F5 & F15 Series Delfield ™ 16 For customer service, call (800) 733-8829, (800) 733-8821, Fax (989) 773-3210, www.delfield.
F5 & F15 Series Service and Installation Manual Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. • A maximum of 1-hour is allowed to diagnose a defective component. • A maximum of 1-hour is allowed for retrieval of parts not in stock. • A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed.
F5 & F15 Series Service and Installation Manual Standard One Year Limited Warranty (One year parts, 90 days labor) The Delfield Company (“Delfield”) warrants to the Original Purchaser of the Delfield product (herein called the “Unit”) that such Unit, and all parts thereof, will be free from defects in material and workmanship under normal use and service for a period of one (1) year from the date of shipment of the Unit to the Original Purchaser or, if the Original Purchaser returns the warranty card com
F5 & F15 Series Service and Installation Manual Additional Four Year Protection Plan Delfield Model# Serial # (For Motor-Compressor Only) Installation Date In addition to the Standard One Year Warranty on the Motor-Compressor contained in the above listed Delfield product (the “Unit”), The Delfield Company (“Delfield”) also agrees to repair, or exchange with similar or interchangeable parts in design and capacity at Delfield’s option, the defective Motor-Compressor contained in the Unit (the “Motor-C
Delfield ™ ® Covington, TN Mt. Pleasant, MI Thank you for choosing Delfield! Help is a phone call away. Help our team of professional, courteous customer service reps by having your model number and serial number available at the time of your call (800) 733-8829 Model:_______________ S/N: ________________________ Installation Date:_____________ For a list of Delfield’s authorized parts depots, visit our website at www.delfield.com Delfield ™ ® 980 S. Isabella Rd., Mt. Pleasant, MI 48858, U.S.A.
