International F5 and F15 Series Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately.
International F5 & F15 Series Service and Installation Manual Important Warning And Safety Information WARNING Read This Manual Thoroughly Before Operating, Installing, Or Performing Maintenance On The Equipment. WARNING Failure To Follow Instructions In This Manual Can Cause Property Damage, Injury Or Death. WARNING Do Not Store Or Use Gasoline Or Other Flammable Vapors Or Liquids In The Vicinity Of This Or Any Other Appliance.
International F5 & F15 Series Service and Installation Manual Contents Receiving & Inspecting Equipment....................................................3 Serial Number Location.....................................................................4 Warranty Information.........................................................................4 Regulatory Certifications....................................................................4 Specifications.........................................................
International F5 & F15 Series Service and Installation Manual Serial Number Location The serial number on all self-contained F5 Series units is located near the condensing unit. On all remote F5 Series units the serial number is located on the drop-in frame. The serial number on all self-contained F15 Series units is located behind the compressor housing. On all remote F15 Series units the serial number is located behind the six inch panel in the base.
International F5 & F15 Series Service and Installation Manual Export F5 Series Specifications 24” (61cm) Deep Self-Contained Drop-In Refrigerated Display Cases Storage capacity FT3/L Volts/Hertz/ Phase F5MC48N-E 18.07/512 F5SC48N-E System Cabinet Load Capacity BTU/ BTU/Hour Hour Amps Max. Lamp Watts 230-240/ 50/1 6.0 25 1215 18.97/537 230-240/ 50/1 6.0 25 F5PC48N-E 18.97/537 230-240/ 50/1 6.0 F5MC72N-E 28.05/794 230-240/ 50/1 F5SC72N-E 28.05/794 F5PC72N-E 29.47/834 Model H.P.
International F5 & F15 Series Service and Installation Manual Export F15 Series Specifications 24” (61cm) Deep Self-Contained Serview Refrigerated Display Cases Shelf Capacity FT2/CM2 Display/Base Storage Capacity FT3/L Display/Base Volts/Hertz/ Phase F15MC48N-E 18.78/17447 3.4/3159 18.07/512 9.11/258 230-240/ 50/1 6.0 25 1569 F15SC48N-E 21.05/19556 3.4/3159 18.97/537 9.11/2.58 230-240/ 50/1 6.0 25 F15PC48N-E 21.05/19556 3.4/3159 18.97/537 9.11/258 230-240/ 50/1 6.0 F15MC72N-E 29.
International F5 & F15 Series Service and Installation Manual Installation: Self-Contained F5 Series Location Units represented in this manual are for indoor use only. All self-contained units were tested at the factory to assure proper operation. The unit should not be installed directly next to high heat generating equipment (ranges, griddles, etc.). Be sure the location chosen has a counter strong enough to support the total weight of the cabinet and contents.
International F5 & F15 Series Service and Installation Manual Installation: Self-Contained F15 Series Location Plumbing Units represented in this manual are for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. A fully loaded model may weigh as much as 3,000 pounds! Reinforce the floor as necessary to provide for maximum loading. For the most efficient refrigeration, be sure to provide good air circulation inside and out.
International F5 & F15 Series Service and Installation Manual Shelf Installation Display Lock Operation Display cases come with four epoxy coated wire shelves that are adjustable in 3-3/4" increments. Maximum weight for shelves is 75 pounds. Overloading shelves can damage equipment or CAUTION cause bodily injury. At the factory, the keys are taped to the display case. Follow the directions below to lock and unlock the display case. To lock: Line up key ridge with red dot.
International F5 & F15 Series Service and Installation Manual Display Temperature Control Settings The display temperature control is located on the evaporator assembly on the ceiling of the display case. It is field adjustable and does not require a service agent. The factory setting is 2.5. Set toward 1 for higher temperatures and toward 7 for lower temperatures. Please make small incremental adjustments if a temperature adjustment is necessary.
International F5 & F15 Series Service and Installation Manual Maintenance Door Gasket Maintenance Door gaskets require regular cleaning to prevent mold and mildew build up and also to retain the elasticity of the gasket. Gasket cleaning can be done with the use of warm soapy water. Avoid full strength cleaning products on gaskets as this can cause them to become brittle and crack. Never use sharp tools or knives to scrape or clean the gasket.
International F5 & F15 Series Service and Installation Manual Maintenance, continued Doors/Hinges Over time and with heavy use the doors hinges may become loose. If this happens tighten the screws that mount the hinge brackets to the frame of the unit. Loose or sagging doors can cause the hinges to pull out of the frame, which may damage both the doors and the hinges. In some cases this may require qualified service agents or maintenance personnel to perform repairs.
International F5 & F15 Series Service and Installation Manual Condenser Air Flow: F5 F5 units are designed to be operated with two supplied louvered panels for proper air flow. Failure to provide the proper air flow will void the warranty. Louver cut-outs are 22" by 11" (55.9cm by 27.9cm) typical. Cut-outs are to begin a maximum of 4.00" (10.2cm) from the counter-top. Proper installation must provide for air flow to and from the condensing unit. Install as shown below.
International F5 & F15 Series Service and Installation Manual Sliding Door All Delfield F5 Series and F15 Series display cases feature a sliding door assembly. A typical sliding door assembly is shown in the illustration at right. Maintenance Frequent, regular cleaning with a mild soap and water solution will keep the tracks free of foreign matter and will insure many years of service. The glass may be cleaned with one of the many commercial glass cleaners currently available.
International F5 & F15 Series Service and Installation Manual Condensing Unit Assembly 1/2 H.P.
International F5 & F15 Series Service and Installation Manual Fluorescent Light Fixture 7 1 Key Part# Description - 000-406-0039 Complete assembly, 60" 000-406-0037 Complete assembly, 36” 000-406-0038 Complete assembly, 48” 1 313-146-0032 cap, end, top mtg, pigtail, -rem. 2 313-146-0033 cap, end, top mtg, blank, -rem. 3 376-A0M-0055 diffuser, fluor. light, 36” 376-A0M-0056 diffuser, fluor. light, 48" 376-A0M-0057 diffuser, fluor.
International F5 & F15 Series Service and Installation Manual F15 Base Evaporator Assembly 1 4 2 3 6 5 9 8 7 Key 1 2 3 4 5 6 7 8 9 - Part Number 000-248-0033 2160024 2160025 3516095 030-232-0003 MCP00140 030-233-0001 000-BNH-0030 030-234-0003 030-233-0002 2184317 2194808 2194809 Description Coil Assembly, R404A, Ref Guard, fan, 4.
International F5 & F15 Series Service and Installation Manual Wiring Diagram: Self-Contained F5 & F15 Series N 18 For customer service, call (800) 733-8829, (800) 733-8821, Fax (989) 773-3210, www.delfield.
International F5 & F15 Series Service and Installation Manual Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. A maximum of 1-hour is allowed to diagnose a defective component. A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed. Actual travel to be charged.
Covington, TN Mt. Pleasant, MI Thank you for choosing Delfield! Help is a phone call away. Help our team of professional, courteous customer service reps by having your model number and serial number available at the time of your call (800) 733-8829. Model:________________________ S/N: _______________________ Installation Date:________________ For a list of Delfield’s authorized parts depots, visit our website at www.delfield.com Register your Delfield warranty online. Go to www.delfield.
