Shelleymatic® by Delfield Milk, Ice Cream and Milk & Ice Cream Dispensers Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately. See page 2.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Serial Number Location Contents Serial Number Location.............................................................. 2 Receiving and Inspecting Equipment......................................... 2 Specifications.............................................................................. 3 Installation................................................................................4-5 Operation...................................
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Specifications Model H.P. Loading/Dispensing Length Depth Height Weight (lbs) Amps (115V) NEMA Plug BTU Load Evap BTU/TD BTU Capacity Ref/Charge Self-contained free-standing milk or beverage dispensers N-520 1/4 sliding top lids 29” x 28” x 36” 327 5.0 5-15P 189 33/31º 1035 134a/16oz N-860 1/4 sliding top lids 42” x 28” x 36” 392 5.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Installation Location These units are intended for indoor use only. Be sure the location chosen has a floor strong enough to support the total weight of the cabinet and contents. Units in this product line can weigh as much as 1500 pounds when it is fully stocked. Reinforce the floor as necessary to provide for maximum loading. For the most efficient refrigeration, be sure to provide good air circulation inside and out.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Installation Continued How to adjust self-leveling dispenser Tools Needed: One small flat head screw driver; One Phillips head screw driver. 1. Always wear safety glasses when adjusting your dispenser. Also, lock brakes on mobile units before beginning. 2. Unload dispenser and remove stainless steel load tray by lifting straight up and set it aside (see figure 1).
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Operation: N, N6/10/14, NDF, NLFAC, MF & MFSC Series N, N6/10/14, NDF, NLFAC and MFSC Series milk dispensers are set at the factory to maintain temperatures between 36°F and 40°F. No further adjustment should be necessary. To begin operation on self-contained models, plug the electrical supply cord into a receptacle with the correct voltage. Remote models will require a connection to a separate refrigeration system.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Maintenance Door Gasket Maintenance Door gaskets require regular cleaning to prevent mold and mildew build up and also to retain the elasticity of the gasket. Gasket cleaning can be done with the use of warm soapy water. Avoid full strength cleaning products on gaskets as this can cause them to become brittle and crack. Never use sharp tools or knives to scrape or clean the gasket.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Wiring Diagrams MODELS — MFSC, & RFFSC L1 N G N G CONDENSING UNIT PRESSURE CONTROL MODELS — N, SCF, NSCF, & NDF L1 ON/OFF SWITCH CONDENSING UNIT PRESSURE CONTROL MODEL — NLFAC L1 N CONDENSING UNIT THERMOSTAT EVAP. FANS For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts - Condensing Units 1 2 3 4 5 1 2 9 3 4 5 8 9 10 11 8 7 6 7 6 Condensing Unit Condensing Unit Key Part Number Description Key Part Number Description - 000-BN5-0030 Condensing Unit - 000-BN5-003G Condensing Unit 1 3526999 Compressor, Danfoss, NF5.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts - Elevator Assemblies 6 5 1 4 3 1 2 7 2 6 3 5 4 Elevator Assembly Elevator Assembly Key Part Number Description - 000-546-Z0002 Elevator Assembly, Large - 000-546-0035 Elevator assembly, 22.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts NLFAC8 3516059 Thermometer, Digital 3516172 Blade, fan, evaporator 3516062 Valve, Expansion, R134A, RFG 031-264-0000 Bracket, Evaporator Fan Motor *271-BGF-0003 Divider, Milk Crate, NLFAC 3234783 Caster, 5, Plate, Swivel, Break *359-411-0040 Louver, 13.00 X 25.00 3234156 Catch, Magnetic, Snap-In *377-AZ0-0004 Bolt, Lock 3516065 Coil, Evaporator, 3.00” X 24.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts N-520, 860, 1200 & 1530 000-AYP-0034 Lid Assembly, Bottom Sliding, N10/14 *265-774-0039 Carrier, elevator 000-AYP-0030 Lid Assembly, Top Sliding, N6 AE540AT-238-J7 Compressor, Tecumseh 000-AYP-0031 Lid Assembly, Top Sliding, N10 3526674 Condensing Unit, 1/4HP, Hi, R134A 000-AYP-0032 Lid Assembly, Top Sliding, N14 2183348 Cord, power, 16/3 W/Nema 5-15P 3234105 Locknut/Washer, 1” Drain *030-392-
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts NDF-18 SCF-32 6230170 Bumper, Corner, Small, PVC 372-395-Z000B Carrier, Large Ice Cream 3234180 Caster, 4, Plate, Swivel, Break 2193927 Control, Pressure, Low 3234307 Catch, Door 2183348 Cord, power, 16/3 W/Nema 5-15P AE630AT-602-J7 Compressor *030-392-0000 Divider, Shelley IC Tank 3526675 Condensing Unit, 1/3HP, Hi 3234242 Drain, Plastic, 1IPS, 2.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts MFSC-31, MFSC-44, MFSC-57, MFSC-2821 MF-2020 372-395-Z000B Carrier, ice cream 1701278 Cover, expansion valve AE540AT-238-J7 Compressor, Tecumsh 3234242 Drain, Plastic, 1IPS, 2.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Parts RFFSC-103 372-395-Z000B Carrier, Large Ice Cream 2193927 Control, Pressure, Low 2183348 Cord, Lead, 16/3 W/Nema 5-15 1701278 Cover, Expansion Valve, Molded *030-392-0000 Divider, Shelley IC Tank 3234242 Drain, Plastic, 1IPS, 2.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Replacement Part Prints 3516265 - Valve, EPR, 3/8 ODF 000-BI7-0030 - Cover assembly, NLFAC8 000-BI7-0031 - Cover Assembly, Lift, NLFAC-12 000-BI7-0032 - Cover Assembly, Lift, NLFAC-16 030-392-0000 - Divider, Shelley IC Tank 030-392-0030 - Divider, Tray, MF, FF, RFF, SCF Series 356-AZD-0000 - Louver, 13.5” x 9” 356-AZD-0001 - Louver, 13.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Standard Labor Guidelines To Repair Or Replace Parts On Delfield Equipment Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. • • • • A maximum of 1-hour is allowed to diagnose a defective component. A maximum of 1-hour is allowed for retrieval of parts not in stock. A maximum travel distance of 100 miles round trip and 2-hours will be reimbursed.
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Standard One Year Limited Warranty One Year Parts, 90 Days Labor The Delfield Company (“Delfield”) warrants to the Original Purchaser of the Delfield product (herein called the “Unit”) that such Unit, and all parts thereof, will be free from defects in material and workmanship under normal use and service for a period of one (1) year from the date of shipment of the Unit to the Original Purchaser or, if the Original Purchaser ret
Milk, Ice Cream & Milk & Ice Cream Dispensers Service and Installation Manual Additional Four Year Protection Plan Delfield Model# Serial # (For Motor-Compressor Only) Installation Date In addition to the Standard One Year Warranty on the MotorCompressor contained in the above listed Delfield product (the “Unit”), The Delfield Company (“Delfield”) also agrees to repair, or exchange with similar or interchangeable parts in design and capacity at Delfield’s option, the defective Motor-Compressor contai
Covington, TN Mt. Pleasant, MI Thank you for choosing Delfield! Help is a phone call away. Help our team of professional, courteous customer service reps by having your model number and serial number available at the time of your call (800) 733-8829. Model:_____________________ S/N: ____________________ Installation Date:_____________ For a list of Delfield’s authorized parts depots, visit our website at www.delfield.com. 980 S. Isabella Rd., Mt. Pleasant, MI 48858, U.S.A.
