Dell™ XPS M140 Service Manual Dell™ XPS M140 Service Manual Before You Begin Display Assembly and Display Latch System Components Palm Rest Internal Card With Bluetooth® Wireless Technology Microprocessor Thermal-Cooling Assembly Hard Drive Fan Optical Drive Microprocessor Module Memory Module and Modem Speakers Hinge Cover System Board Keyboard BIOS Updates Coin-Cell Battery Pin Assignments for I/O Connectors Wireless Mini PCI Card Notes, Notices, and Cautions NOTE: A NOTE indicates imp
Before You Begin: Dell XPS M170 Service Manual Back to Contents Page Before You Begin Dell™ XPS M140 Service Manual Preparing to Work Inside the Computer Recommended Tools Computer Orientation Screw Identification Preparing to Work Inside the Computer CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: Only a certified service technician should perform repairs on your computer.
Before You Begin: Dell XPS M170 Service Manual NOTICE: To avoid damaging the system board, wait 10 to 20 seconds before disconnecting any attached devices. 5. Disconnect all attached devices. 6. Disconnect all external cables from the computer. 7. Close the display and turn the computer upside down on a flat work surface. NOTICE: To avoid damaging the system board, you must remove the main battery before servicing the computer. 8.
Before You Begin: Dell XPS M170 Service Manual Computer Orientation 1 front 4 right 2 left 3 back Screw Identification The following chart provides the number of screws used to secure the various system components and their corresponding sizes. When removing and replacing components, print the screw identification chart as a placemat to lay out and keep track of the screws. Optical Drive: Modem: Bluetooth Module: (1 each – optional) (1 each) (1 each) file:///C|/Users/santhosh_v.
Before You Begin: Dell XPS M170 Service Manual Hinge Cover: Display Assembly: Display Bezel (screw): (2 each) (4 each) (6 each) Display Bezel (rubber bumper): Display Panel: Palm Rest (top): (6 each) (4 each) Palm Rest (bottom): Fan: Speakers: (11 each) (3 each) (3 total) System Board (top): System Board (bottom): (1 each) (2 each) (6 each) file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/begin0.
Before You Begin: Dell XPS M170 Service Manual Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/begin0.
System Components: Dell™ XPS M140 Service Manual Back to Contents Page System Components Dell™ XPS M140 Service Manual NOTICE: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. Exploded View of the Computer file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/system0.
System Components: Dell™ XPS M140 Service Manual 1 display assembly 6 optical drive 11 microprocessor thermal-cooling assembly 2 hinge cover 7 main battery 12 microprocessor 3 keyboard 8 computer base 13 fan 4 palm rest (with touch pad) 9 hard drive 5 system board 10 speakers Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/system0.
System Components: Dell™ XPS M140 Service Manual file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/system0.
Internal Card With Bluetooth® Wireless Technology: Dell™ XPS M140 Service Manual Back to Contents Page Internal Card With Bluetooth® Wireless Technology Dell™ XPS M140 Service Manual Removing the Bluetooth Module Replacing the Bluetooth Module NOTE: If you ordered the optional internal card with Bluetooth wireless technology at the same time that you ordered your computer, the card is already installed.
Internal Card With Bluetooth® Wireless Technology: Dell™ XPS M140 Service Manual 3. Remove the M2 x 3-mm screw securing the Bluetooth module and set it aside. 1 Bluetooth module 2 M2 x 3-mm screw 4. Lift the Bluetooth module from its compartment. 5. Grasp the card and gently pull it apart from the connector cable. NOTE: Do not disconnect the Bluetooth connector cable from the system board. 1 Bluetooth module 2 Bluetooth module connector 3 Bluetooth connector cable file:///C|/Users/santhosh_v.
Internal Card With Bluetooth® Wireless Technology: Dell™ XPS M140 Service Manual Replacing the Bluetooth Module CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer. 2.
Hard Drive: Dell™ XPS M140 Service Manual Back to Contents Page Hard Drive Dell™ XPS M140 Service Manual Removing the Hard Drive Replacing the Hard Drive Returning a Hard Drive to Dell Removing the Hard Drive CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. CAUTION: Do not touch the metal housing of the hard drive if you remove the hard drive from the computer while the drive is hot.
Hard Drive: Dell™ XPS M140 Service Manual 1 hard drive cover 2 captive screws (2) NOTICE: When the hard drive is not in the computer, store it in protective, antistatic packaging. See "Protecting Against Electrostatic Discharge" in the Product Information Guide. 3. Use the pull-tab to slide the hard drive toward the screw holes, then lift the drive straight up to remove it from the computer.
Hard Drive: Dell™ XPS M140 Service Manual NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer. 2. Follow the instructions in Removing the Hard Drive. NOTICE: Use firm and even pressure when sliding the hard drive into place. Excessive force may result in damage to the connector. 3.
Hard Drive: Dell™ XPS M140 Service Manual file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/hdd0.
Optical Drive: Dell™ XPS M140 Service Manual Back to Contents Page Optical Drive Dell™ XPS M140 Service Manual About the Device Security Screw Removing the Optical Drive Replacing the Optical Drive About the Device Security Screw NOTE: You do not need to install the device security screw unless you want to prevent the optical drive from being easily removed. Your Dell™ computer ships with a CD/DVD drive installed in the optical drive bay along with an M2.5 x 8-mm device security screw.
Optical Drive: Dell™ XPS M140 Service Manual 1 indention 2 M2.5 x 8-mm device security screw (optional) 3. Insert the screwdriver into the indention and push the notch on the metal tab to release the drive from the bay. 1 metal tab 2 optical drive 4. Pull the drive out of the bay. file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/opticald.
Optical Drive: Dell™ XPS M140 Service Manual Replacing the Optical Drive CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. 1. Follow the instructions in Preparing to Work Inside the Computer. 2. Follow the instructions in Removing the Optical Drive. 3. Slide the new drive into the bay until it snaps securely into place. 4. Replace the M2.5 x 8-mm device security screw (optional).
Memory Module and Modem: Dell™ XPS M140 Service Manual Back to Contents Page Memory Module and Modem Dell™ XPS M140 Service Manual Removing a Memory Module Replacing a Memory Module Modem Your Dell computer comes equipped with two memory slots/connectors labeled DIMM A and DIMM B. DIMM A (located under the keyboard) holds the primary memory module as configured from the factory. DIMM B (located on the bottom of the computer) holds any additional memory you may have ordered.
Memory Module and Modem: Dell™ XPS M140 Service Manual 1 memory module cover 2 captive screws (2) NOTICE: To prevent damage to the memory module connector, do not use tools of any kind to spread the metal clips that secure the module. 3. Use your fingertips to carefully spread apart the metal clips securing each end of the memory module until the module pops up. 1 memory module 2 metal retention clips (2) 4. Remove the module from the connector at a 45-degree angle. file:///C|/Users/santhosh_v.
Memory Module and Modem: Dell™ XPS M140 Service Manual Memory Module DIMM A 1. Follow the instructions in Preparing to Work Inside the Computer. 2. Remove the hinge cover (see Removing the Hinge Cover). 3. Remove the keyboard (see Removing the Keyboard). 4. Loosen the two captive screws securing the memory module cover, then remove the cover and set it aside.
Memory Module and Modem: Dell™ XPS M140 Service Manual 5. Use your fingertips to carefully spread apart the metal clips securing each end of the memory module until the module pops up. 1 memory module 2 metal retention clips (2) 6. Remove the memory module from the connector at a 45-degree angle. Replacing a Memory Module CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Memory Module and Modem: Dell™ XPS M140 Service Manual NOTICE: If you need to install more than one memory module, install a memory module in the memory slot labeled DIMM A before installing a module in the slot labeled DIMM B. Insert memory modules at a 45-degree angle to avoid damaging the connector. NOTE: If a memory module is not installed properly, the computer may not boot. No error message will be displayed for this type of failure. 1.
Memory Module and Modem: Dell™ XPS M140 Service Manual As the computer boots, it detects the installed memory. The system configuration information remains the same. If You Are Adding or Upgrading Memory As the computer boots, it detects the change in memory and automatically updates the system configuration information. Confirming Installed Memory To confirm the amount of memory installed in the computer, use one of the following methods: Click the Start button, then click Help and Support.
Memory Module and Modem: Dell™ XPS M140 Service Manual 1 modem/Mini PCI/wireless cover 2 captive screws (2) 3. Disconnect the antenna cables from the Mini PCI card, if applicable. NOTE: The Mini PCI card is optional and may not be installed if one was not ordered with the computer. 1 Mini PCI antenna cables 4. Remove the M2 x 3-mm screw securing the modem to the system board and set it aside. file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/upgrades.
Memory Module and Modem: Dell™ XPS M140 Service Manual 5. Pull straight up on the attached pull-tab to disconnect the modem from the connector on the system board. 6. Disconnect the modem cable from the modem. 1 modem 3 M2 x 3-mm screw 2 modem cable 4 system board connector 5 pull tab Replacing the Modem CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Memory Module and Modem: Dell™ XPS M140 Service Manual Align the modem with the screw hole and press the modem into the connector on the system board. 5. Replace the M2 x 3-mm screw and secure the modem to the system board. 6. Connect the Mini PCI antenna cables, if applicable. 7. Replace the modem/Mini PCI/wireless cover and tighten the screws. Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/upgrades.
Hinge Cover: Dell™ XPS M140 Service Manual Back to Contents Page Hinge Cover Dell™ XPS M140 Service Manual Removing the Hinge Cover Replacing the Hinge Cover Removing the Hinge Cover CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Hinge Cover: Dell™ XPS M140 Service Manual 1 hinge cover 2 indent Replacing the Hinge Cover CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer.
Keyboard: Dell™ XPS M140 Service Manual Back to Contents Page Keyboard Dell™ XPS M140 Service Manual Removing the Keyboard Replacing the Keyboard Removing the Keyboard CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Keyboard: Dell™ XPS M140 Service Manual 1 keyboard 2 keyboard retention tabs 3 palmrest 4. Lift the keyboard and hold it up and slightly forward to allow access to the keyboard connector. 5. Release the latch on the system board connector to disconnect the keyboard cable. file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/keyboard.
Keyboard: Dell™ XPS M140 Service Manual 1 keyboard 3 keyboard connector tabs 5 system board connector slots 2 keyboard cable 4 system board connector 6 keyboard tabs (6) Replacing the Keyboard CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Coin-Cell Battery: Dell™ XPS M140 Service Manual Back to Contents Page Coin-Cell Battery Dell™ XPS M140 Service Manual Removing the Coin-Cell Battery Replacing the Coin-Cell Battery Removing the Coin-Cell Battery CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Coin-Cell Battery: Dell™ XPS M140 Service Manual 1 coin-cell battery Replacing the Coin-Cell Battery CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer. 2.
Wireless Mini PCI Card: Dell™ XPS M140 Service Manual Back to Contents Page Wireless Mini PCI Card Dell™ XPS M140 Service Manual Removing the Mini PCI Card Replacing the Mini PCI Card NOTE: If you ordered the optional Mini PCI card at the same time that you ordered your computer, the card is already installed. Removing the Mini PCI Card CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Wireless Mini PCI Card: Dell™ XPS M140 Service Manual 3. Disconnect the antenna cables from the Mini PCI card. 1 antenna cables NOTICE: To prevent damage to the Mini PCI card connector, do not use tools of any kind to spread the metal clips that secure the Mini PCI card. 4. Use your fingertips to carefully spread apart the metal clips securing each end of the Mini PCI card until the card pops up. 1 Mini PCI card 2 metal retention clips (2) 5.
Wireless Mini PCI Card: Dell™ XPS M140 Service Manual Replacing the Mini PCI Card CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer 2.
Wireless Mini PCI Card: Dell™ XPS M140 Service Manual 1 Mini PCI card 4. Connect the antenna cables to the Mini PCI card. Make certain that the cable connectors snap securely into place. 1 antenna cables 5. Replace the modem/Mini PCI/wireless cover and tighten the screws. Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/minipci0.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual Back to Contents Page Display Assembly and Display Latch Dell™ XPS M140 Service Manual Display Assembly Display Bezel Display Panel Display Latch Display Assembly Removing the Display Assembly CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual 1 display assembly 3 antenna cable retaining clips 5 display cable 2 Mini PCI antenna cables 4 antenna cable connectors 6 M2.5 x 5-mm screws (4) Replacing the Display Assembly CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual Display Bezel Removing the Display Bezel CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer. 2.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual 1 display bezel 2 rubber bumpers (6) 3 M2.5 x 5-mm screws (6) 4 inside edge of bezel Replacing the Display Bezel CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual Display Panel Removing the Display Panel CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer. 2.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual 1 display panel 2 M2 x 3-mm screws (6) 3 display cover 8. Press inward on the metal clamps on both sides of the top flex-cable connector and gently pull to disconnect the top flex-cable connector from the display locking connector. 9. Use the pull-tab to disconnect the bottom flex-cable connector from the inverter connector. file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/display0.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual 1 back of display panel 3 metal clamps 2 top flex-cable connector 4 bottom flex-cable connector 5 inverter connector Replacing the Display Panel CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual 2. Remove the hinge cover (see Removing the Hinge Cover). 3. Remove the keyboard (see Removing the Keyboard). 4. Remove display assembly (see Removing the Display Assembly). 5. Remove the display bezel (see Removing the Display Bezel). NOTICE: The display latch spring is not physically connected to the latch assembly. Exercise care that the spring is not lost. 6.
Display Assembly and Display Latch: Dell™ XPS M140 Service Manual 3. Insert the guide post of the new display latch assembly (with spring) into the slot on the display (top) cover. NOTE: When the guide post is in position, the display latch assembly may automatically snap into place. 4. Press the remainder of the display latch assembly into place, as needed. 5. Replace the display bezel (see Replacing the Display Bezel). 6. Replace display assembly (see Replacing the Display Assembly). 7.
Palm Rest: Dell™ XPS M140 Service Manual Back to Contents Page Palm Rest Dell™ XPS M140 Service Manual Removing the Palm Rest Replacing the Palm Rest Removing the Palm Rest CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Palm Rest: Dell™ XPS M140 Service Manual 1 modem/Mini PCI/wireless cover 2 captive screws (2) 8. Remove the eleven M2.5 x 8-mm screws securing the palm rest from the bottom of the computer. 1 M2.5 x 8-mm screws (11) 9. Turn the computer over and remove the four M2.5 x 5-mm screws securing the top of the palm rest. NOTICE: Release the locking tabs on both sides of the system board connector before attempting to remove the touch pad or LED cable.
Palm Rest: Dell™ XPS M140 Service Manual connector. 10. Disconnect the touch pad cable. Use a plastic scribe to release the locking clips on both sides of the system board connector, and then gently pull to disconnect the touch pad connector from the system board connector. 11. Disconnect the LED board cable. Use a plastic scribe to release the locking clips on both sides of the system board connector, and then gently pull to disconnect the LED board connector from the system board connector. 1 M2.
Palm Rest: Dell™ XPS M140 Service Manual 1 palmrest 2 hinge brackets Replacing the Palm Rest CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer 2.
Palm Rest: Dell™ XPS M140 Service Manual 10. Replace the display assembly (see Replacing the Display Assembly). 11. Replace the keyboard (see Replacing the Keyboard). 12. Replace the hinge cover (see Replacing the Hinge Cover). 13. Replace the optical drive (see Replacing the Optical Drive). Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/palmrest.
Microprocessor Thermal-Cooling Assembly: Dell™ XPS M140 Service Manual Back to Contents Page Microprocessor Thermal-Cooling Assembly Dell™ XPS M140 Service Manual Removing the Microprocessor Thermal-Cooling Assembly Replacing the Microprocessor Thermal-Cooling Assembly Removing the Microprocessor Thermal-Cooling Assembly CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Microprocessor Thermal-Cooling Assembly: Dell™ XPS M140 Service Manual 1 microprocessor thermal-cooling assembly 2 captive screws (4) Replacing the Microprocessor Thermal-Cooling Assembly CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer.
Fan: Dell™ XPS M140 Service Manual Back to Contents Page Fan Dell™ XPS M140 Service Manual Removing the Fan Replacing the Fan Removing the Fan CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Fan: Dell™ XPS M140 Service Manual 1 fan 2 M2.5 x 5-mm screws (3) 3 fan connector 4 system board connector Replacing the Fan CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Fan: Dell™ XPS M140 Service Manual file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/fan0.
Microprocessor Module: Dell™ XPS M140 Service Manual Back to Contents Page Microprocessor Module Dell™ XPS M140 Service Manual Removing the Microprocessor Module Replacing the Microprocessor Module Removing the Microprocessor Module CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Microprocessor Module: Dell™ XPS M140 Service Manual thermal pads. 3. Remove the microprocessor thermal-cooling assembly (see Removing the Microprocessor Thermal- Cooling Assembly). NOTICE: To avoid damaging the microprocessor, hold the screwdriver so that it is perpendicular to the microprocessor module when turning the cam screw. 4. To loosen the ZIF-socket cam lock, use a small, flat-blade screwdriver to rotate the ZIF-socket cam screw counterclockwise until it comes to the cam stop.
Microprocessor Module: Dell™ XPS M140 Service Manual NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer NOTICE: Handle the microsprocessor module with care. Hold the microsprocessor module by its edges and do not touch the processor die (the small chip in the center of the module). 2.
Speakers: Dell™ XPS M140 Service Manual Back to Contents Page Speakers Dell™ XPS M140 Service Manual Removing the Speakers Replacing the Speakers Removing the Speakers CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Speakers: Dell™ XPS M140 Service Manual 1 speakers (2) 3 speaker cable 2 M2.5 x 5-mm screws (3) 4 speaker connector 5 guide post slots (4) Replacing the Speakers CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1.
Speakers: Dell™ XPS M140 Service Manual 8. Replace the display assembly (see Replacing the Display Assembly). 9. Replace the keyboard (see Replacing the Keyboard). 10. Replace the hinge cover (see Replacing the Hinge Cover). 11. Replace the optical drive (see Replacing the Optical Drive). Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/speakers.
System Board: Dell™ XPS M140 Service Manual Back to Contents Page System Board Dell™ XPS M140 Service Manual Removing the System Board Replacing the System Board Removing the System Board CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide.
System Board: Dell™ XPS M140 Service Manual 14. Remove the palmrest (see Removing the Palm Rest). 15. Remove the two M2 x 3-mm screws securing the system board from the bottom of the computer. 1 M2 x 3-mm screws (2) 16. Turn the computer over so that the bottom is facing down and remove the M2.5 x 5-mm screw securing the system board. 17. Disconnect the fan cable from the system board. 18. Disconnect the speaker cable from the system board. 19. Disconnect the modem cable from the system board.
System Board: Dell™ XPS M140 Service Manual 1 M2.5 x 5-mm screw 3 speaker connector 2 system board 4 fan connector 5 modem connector 20. With the rear of the computer facing you, gently lift the system board assembly from the left side, then slide the system board assembly to the left and lift up on the right side to raise the assembly out of the computer.
System Board: Dell™ XPS M140 Service Manual Replacing the System Board CAUTION: Before you perform any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching an unpainted metal surface (such as the back panel) on the computer. 1. Follow the instructions in Preparing to Work Inside the Computer. 2.
BIOS Updates: Dell™ XPS M140 Service Manual Back to Contents Page BIOS Updates Dell™ XPS M 140 Service Manual Flashing the BIOS Flashing the BIOS NOTICE: Plug the AC adapter into a known-good power source to prevent a loss of power. Failure to do so may cause damage to the computer. 1. Ensure that the AC adapter is plugged in and that the main battery is properly installed. 2. Turn on the computer.
Pin Assignments for I/O Connectors: Dell™ XPS M140 Service Manual Back to Contents Page Pin Assignments for I/O Connectors Dell™ XPS M140 Service Manual USB Connector Video Connector S-Video TV-Out Connector IEEE 1394 Connector USB Connector Pin Signal 1 USB5V+ 2 USBP– 3 USBP+ 4 GND Video Connector Pin Signal Pin Signal 1 CRT_R 9 5V+ 2 CRT_G 10 GND 3 CRT_B 11 MONITOR_DETECT– file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/pinouts0.
Pin Assignments for I/O Connectors: Dell™ XPS M140 Service Manual 4 NC 12 DDC_DATA 5 GND 13 CRT_HS 6 GND 14 CRT_VS 7 GND 15 DDC_CLK 8 GND S-Video TV-Out Connector S-Video Pin Signal 1 GND 2 GND 3 DLUMA-L 4 DCRMA-L Composite Video Pin Signal 5 NC 6 DCMPS-L 7 GND IEEE 1394 Connector Pin Signal file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/pinouts0.
Pin Assignments for I/O Connectors: Dell™ XPS M140 Service Manual 1 TPB– 2 TPB+ 3 TPA– 4 TPA+ Back to Contents Page file:///C|/Users/santhosh_v.ASIA-PACIFIC/Desktop/Hawke/New%20folder/pinouts0.