DELUX® MAVERICK SOFT WASH SYSTEM
INTRODUCTION Congratulations on your choice of a Delux® Maverick Soft Wash System. We are certain you will be pleased with your purchase. This manual was created to help you get the best results from your new Delux® Maverick Soft Wash System. Please read it carefully and thoroughly to ensure that you learn to use your soft wash system safely. Keep this manual nearby so you can refer to it as needed. If you should decide to sell your Delux® Maverick Soft Wash System, please be sure to include this manual.
Introduction ..................................................................................................................................... 1 What’s In The Box ............................................................................................................................ 4 What You Need to Get Started......................................................................................................... 5 Getting Started ..................................................................
Cam Lock Fitting Pickup tube 200 feet of ½ Inch Rubber Hose Purge Valve Aluminum Frame Accumulator Tank Water Tight Battery Box Delux® 12v Diaphragm Pump 24 Inch PVC Soft Wash Wand The Maverick Soft Wash System is a professional grade soft wash machine for low pressure roof cleaning and house washing. The high strength aluminum tube frame protects a Delux D7150 12v diaphragm pump, a Floject Accumulator, and a water tight battery box.
WHAT’S IN THE BOX DELUX® 12 VOLT DIAPHRAGM PUMP 7 GPM, 100 PSI, Delux® diaphragm pump with a maximum temperature of 160 F. FLOJET ACCUMULATOR TANK The FLOJET Accumulator Tank when used with a diaphragm pump gives you the best of both worlds! High flow when you need it and the ability to restrict the flow for sensitive situations. When the pump starts, liquid enters the reservoir compressing the bladder until the maximum pressure for the pressure switch is reached then the pump shuts off.
WHAT YOU NEED TO GET STARTED A 12 VOLT BATTERY We recommend a Group 24 DeepCycle Marine 12 volt battery with 550 cold cranking amps or higher. A CHEMICAL MIX TANK OR BUCKET Most contractors use a 100 gallon mix tank. GETTING STARTED 1. CONNECT THE BATTERY TO THE SYSTEM USING THE PROVIDED CABLES AND TERMINALS Deep cycle batteries have a two threaded posts with wingnuts on top. Remove the wingnuts and place them off to the side.
Use a deep cycle battery charger when charging the battery while disconnected from the system. As the battery loses power there is a potential for the 30 amp fuse located in the battery box to break. It may also cause the 40/60 SPST Relay located on the head of the pump to fail.If the system does not power on, check the fuse and the relay. If the relay has failed ,inspect the relay under the protective covering for burn marks or also potential rust .