® PORTABLE GASOLINE GENERATORS OWNER’S OPERATION AND INSTALLATION MANUAL Generator Models: RGH3000, RGH3000PR, RGH5500A, RGH5500AIE, RGH7500AIE, and RGH11000AIE IMPORTANT: Read and understand this manual before operating or servicing generator. Improper use of generator can cause serious injury. Keep this manual for future reference.
® PORTABLE GASOLINE GENERATORS SAFETY INFORMATION 1. WARNINGS IMPORTANT: Read this owner’s manual and the engine owner’s manual carefully. Become familiar with this generator before trying to operate or service it. Know its uses, limitations, and any hazards involved. Improper use of generator can cause severe injury or death from explosion, fire, burns, electrical shock, or carbon monoxide poisoning.
OWNER’S MANUAL SAFETY INFORMATION PRODUCT IDENTIFICATION Continued 12. 13. 14. Control Panel 120 Volt Receptacle 120 Volt Receptacle (GFCI) F U E L Full Power Selector Switch 120 VO LT S RE SE TE T ST FU LL PO WE R 12 ON 0 LY 120 Volt Receptacle (Duplex) 12 0 24 0V 12 0/2 40 VO LT S EN M 00 00 05 00 HO RE UR SE S T 1/1 0 RE SE T Provision for Auto-Idle Switch Run Lamp Hour Meter Roll Cage 120/240 Volt Receptacle Gas Tank U E L Circuit Breaker F 11.
® PORTABLE GASOLINE GENERATORS GENERAL INFORMATION Reddy portable generators are rugged and compact. These models provide dependable, trouble-free service. The alternators are brushless with revolving fields. Honda gasoline engines provide long life under heavy use. Honda engines have overhead valves (OHV). This provides high performance with lower fuel consumption. These engines are governed to maintain engine speed of 3600 RPM under load. 3600 RPM engine speed provides 120/240V, 60 Hz power.
OWNER’S MANUAL SPECIFICATIONS MODEL Electrical Rated Wattage Rated Amperage 120 V 240 V Receptacle 120-V Duplex 120-V, 20-A Duplex 120-V, 15-A GFCI 120-V Twist-Lock 120/240-V Twist-Lock 120-V Full-Power Switch 120/240-V, 50-A RGH3000 RGH3000PR RGH5500A RGH5500AIE 2500 2500 5000 7000 10,000 20.8 –– 20.8 –– 41.7 20.8 57 28.3 83.3 41.7 –– –– Yes No No No No –– –– Yes No No No No Yes –– Yes 30 Amp 20 Amp Yes No Yes –– Yes 30 Amp 30 Amp No No Yes –– Yes 30 Amp 30 Amp No Yes 5.
® PORTABLE GASOLINE GENERATORS FULL POWER SELECTOR SWITCH GENERATOR FEATURES OIL ALERT SYSTEM The oil alert system protects the engine from low oil damage. This system automatically shuts down the engine and prevents engine restarting if the oil level falls too low. Note: When this happens, the engine switch remains in the ON position. The oil alert system is wired into the ON/OFF Switch. If this system shuts down the engine, the engine will not start until you add oil.
OWNER’S MANUAL RECEPTACLE CIRCUIT BREAKER GENERATOR FEATURES Continued 2. If the GFCI receptacle tests okay, restore power by pushing the RESET button back in. The test lamp should work at this time. IMPORTANT: You must press the RESET button firmly and fully. It should lock into place. If the GFCI does not lock into place, do not use receptacle. Contact a qualified electrician for repairs. RE The circuit breakers protect the receptacles and alternator. Overloading generator will trip circuit breaker.
® PORTABLE GASOLINE GENERATORS HANDLES AND TOP COVER (Model RGH11000AIE) Follow the steps below to attach the handles and top cover to Model RGH11000AIE: 1. Remove the two bolts, lock nuts, and washers holding side panels to control panel end of roll cage. Insert bolts with washers through two holes in the handle and then back through roll cage and side screen panels (See Figure 8). Tighten the lock nuts against the side screen panels. 2.
OWNER’S MANUAL BATTERY Continued TO ENGINE BLOCK FUL L PO WE R 120 ON LY MOUNTING BATTERY TO GENERATOR 4. See engine owner’s manual for more information. Battery Mounting Bracket S 05 1/10 TO STARTER SOLENOID Figure 14 - Connecting Positive and Negative Cables to Battery (Model RGH7500AIE Shown) L TO STARTER SOLENOID TO ENGINE BLOCK E 3. UR FU 2. Secure battery to generator by battery hold-down system.
® PORTABLE GASOLINE GENERATORS STANDBY INSTALLATION TO HOME OR BUILDING 1. WARNING: Have standby installation performed by a skilled, licensed electrician. Do not let anyone else wire into a utility circuit. Personal injury, equipment damage, or damage to home could occur. 2. IMPORTANT: This generator will not power your entire home. Most home utility electric service is more than 60 amps. This will exceed generator output. Only power needed items during a power outage.
OWNER’S MANUAL OPERATION Model RGH11000AIE also has a 120/240V, 50-amp receptacle (see Figure 17). POWER CORD AND PLUG REQUIREMENTS GENERAL INFORMATION Models RGH3000 and RGH3000PR have only the 120V, 15-amp GFCI duplex receptacle. 120V, 30-amp twist-lock receptacle • NEMA L5-30P plug • Three-wire, 30-amp cord This generator is not large enough to power your entire home. Do not connect generator to any existing electrical circuits. Plug items directly into generator receptacles.
® PORTABLE GASOLINE GENERATORS OPERATION 4. Continued PRESTART Operate generator on a firm, dry, and clean surface. The surface must be level. Protect generator from heavy dust, sand, dirt, rain, or snow. Do not locate generator near standing water and snow. Make sure area is well vented. WARNING: Only responsible adults should use generator. Never let anyone operate generator without proper instructions.
OWNER’S MANUAL OPERATION Continued HONDA 6. ON OFF Engine Switch START Note: The 250 Volt/50 Amp receptacle is not connected through the Auto-Idle circuit. The Auto-Idle switch must be turned off to get full power out of this receptacle (see Figure 26). The Auto-Idle system should be turned OFF when generator is shut down.
® PORTABLE GASOLINE GENERATORS Fuel Valve Lever (Off Position) OPERATION STOPPING ENGINE Continued HIGH ALTITUDE OPERATION IMPORTANT: The engine speed is preset. The throttle is locked in preset position. Do not adjust throttle. This generator will not perform well at high altitudes without proper adjustment. See engine owner’s manual for details. Follow the steps below to stop engine. 1. Remove all electrical loads from generator (see Disconnecting Electrical Loads).
OWNER’S MANUAL MAINTENANCE AND REPAIRS WARNING: Only a qualified electrical service person should service and repair the alternator on this generator. Use only factory approved replacement parts. CAUTION: The engine speed is preset. The throttle is locked in preset position. Do not adjust throttle. Preset position lets engine run at 3600 RPM under load. The engine must maintain 3600 RPM for generator to create correct voltage. Running engine at lower speeds will damage generator and powered items.
® PORTABLE GASOLINE GENERATORS ELECTRICAL COMPONENT SPECIFICATIONS Resistance in Ohms Stator Stator Rotor Rotor Main Auxiliary Primary Secondary Winding * Winding ∆ Winding † Winding † Model RGH3000, RGH3000PR RGH5500A RGH5500AIE RGH7500AIE RGH11000AIE 1.6 0.54 0.54 0.28 0.40 5.9 1.38 1.38 0.78 0.90 6.9 0.61 0.61 0.77 0.37 Capacitor, MFD 450 Volt Diodes (2) 800 Volt 16 50 50 70 80 6 Amp 70 Amp 70 Amp 70 Amp 70 Amp 1.33 2.29 2.29 2.9 0.50 * Connect T2 (green) and T3 (black).
OWNER’S MANUAL WIRING DIAGRAMS Continued White Red Black Red 120/240V 20A Receptacle s1 s2 White • T1 Circuit Breaker To Solenoid Duplex T2 20A, 25A or 30A Circuit Breaker Black White White Black Circuit Breaker 20A Red Hour Meter Black Main Windings Capacitor White T4 T3 Green Red Green Black Red T1 White Green Black Red White Circuit Breaker 20A LINE T4 Yellow • 120V, 30A Receptacle GFCI Black T3 20A, 25A or 30A Full Pwr Selector Switch HOT Black Green White 120
® PORTABLE GASOLINE GENERATORS WIRING DIAGRAMS Continued White White Green Black 125V, 30A GFCI 125V, 15A Receptacle Receptacle Green 125V, 15A Receptacle 250V 30A Receptacle Auto-Idle Control Board 250V 50A Receptacle White White To Auto-Idle Solenoid Circuit Breaker 30A Red Circuit Breaker 45A Circuit Breaker 30A Yellow Circuit Breaker 45A W Run Black Light h Hour Meter Yellow White White n White T3 T2 Black Red Black White Green Black Red T4 ee Black Black T1 Gr Circuit Br
OWNER’S MANUAL TECHNICAL SERVICE REPLACEMENT PARTS You may have further questions about installation, operation, or troubleshooting. If so, contact DESA International’s Technical Service Department at 1-800-323-5190. Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. You can also visit DESA International’s technical service web site at www.desatech.com.
® PORTABLE GASOLINE GENERATORS ILLUSTRATED PARTS LIST 7 1 For Models RGH3000 and RGH3000PR Alternator Assembly 2 4 22 5 6 This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. 3 20 15 14 21 19 13 17 16 7 8 13 15 12 18 9 7 10 11 7 KEY NO.
OWNER’S MANUAL ILLUSTRATED PARTS LIST 23 For Models RGH5500A, RGH5500AIE, and RGH7500AIE Alternator Assembly 15 This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. 22 9 21 19 9 10 8 14 7 18 6 5 13 16 12 4 1 17 2 11 3 PART NUMBER FOR MODEL KEY NO.
® PORTABLE GASOLINE GENERATORS 19 ILLUSTRATED PARTS LIST 18 20 For Model RGH11000AIE Alternator Assembly 13 17 8 21 This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. 15 26 12 24 5 25 10 14 11 23 1 2 6 4 16 22 9 7 3 KEY NO.
OWNER’S MANUAL ILLUSTRATED PARTS LIST 1 For Models RGH3000 and RGH3000PR Roll Cage This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. 2 3 4 3 4 3 7 4 3 3 4 5 6 6 8 5 5 9 4 3 4 3 4 7 3 3 106815 KEY NO.
® PORTABLE GASOLINE GENERATORS ILLUSTRATED PARTS LIST 1 F For Models RGH5500A, RGH5500AIE, and RGH7500AIE Fuel Tank and Roll Cage F U E L 2 4 10 3 10 3 5 7 15 26 4 27 6 7 24 8 6 3 23 25 9 3 24 22 11 13 11 16 21 20 11 14 16 11 13 16 23 11 16 14 12 18 16 17 16 23 13 19 10 16 11 17 16 11 16 11 24 106815
OWNER’S MANUAL ILLUSTRATED PARTS LIST This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. For Models RGH5500A, RGH5500AIE, and RGH7500AIE Fuel Tank and Roll Cage KEY NO.
® PORTABLE GASOLINE GENERATORS ILLUSTRATED PARTS LIST 36 For Model RGH11000AIE Fuel Tank and Roll Cage 35 33 9 9 10 23 37 37 10 25 10 36 10 24 22 32 9 28 29 31 30 2 26 27 18 19 12 20 10 9 18 37 10 25 37 34 10 9 10 21 19 16 17 20 15 14 10 F F U E L 21 1 13 10 4 9 6 5 3 6 7 8 12 11 26 106815
OWNER’S MANUAL ILLUSTRATED PARTS LIST For Model RGH11000AIE Fuel Tank and Roll Cage This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. KEY NO.
® PORTABLE GASOLINE GENERATORS ILLUSTRATED PARTS LIST 2 For Models RGH5500A, RGH5500AIE, and RGH7500AIE Control Panel This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual.
OWNER’S MANUAL ILLUSTRATED PARTS LIST 2 For Model RGH11000AIE Control Panel This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. 14 2 6 16 1 3 Re 12 se 0 t RE SE TE T ST 11 Vo 12 lt Re 7 se t Au 4 to Off 5 Idle 5 On Se lec tor 12 20 15 9 0V p;t Re 8 se Re se t t Re se Re se E 00 NM 00 00 0 HO UR S t t 5 1/10 13 10 4 KEY NO.
® PORTABLE GASOLINE GENERATORS ILLUSTRATED PARTS LIST 12 10 13 6 14 For Solenoid and Control Board Assemblies and Mounting 7 8 10 11 9 8 Solenoid Assembly and Mounting 3 DE IN 5 TE RN AT IO NA L 4 L2 L1 S1 S2 SA 2 1 Control Board Assembly and Mounting 30 106815
OWNER’S MANUAL ILLUSTRATED PARTS LIST For Solenoid and Control Board Assemblies and Mounting This list contains replaceable parts used in your generator. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. KEY NO.
WARRANTY INFORMATION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied. Note: The two-year limited warranty below covers all non-engine parts of this generator including the alternator. Honda warrants the engine.