Full Product Manual

English
English
20 21
BATTERY REPLACEMENT
The battery should last the service life of the unit. Service life is
dependent on a number of factors including but not limited to the
number of recharge cycles, and proper care and maintenance of the
battery by the end user. Contact manufacturer for any information you
may need.
SAFE BATTERY DISPOSAL

Contains a maintenance-free, sealed, non-spillable, lead
acid battery, which must be disposed of properly. Recycling
is required. Failure to comply with local, state and federal
regulations can result in fines, or imprisonment.
Please recycle.
WARNING – To reduce the risk of serious injury or property
damage:
• Do not dispose of the battery in fire as this may result in an explosion.
• Before disposing of the battery, protect exposed terminals with
heavy-duty electrical tape to prevent shorting (shorting can result
in injury or fire).
• Do not expose battery to fire or intense heat as it may explode.
12 VOLT DC ADAPTER PLUG FUSE REPLACEMENT
(OPTIONAL ACCESSORY)
The fuse in the plug end of the 12 Volt DC Adapter protects the
adapter’s charging circuit. If the built-in 120 Volt AC Charger operates,
but the DC charging adapter does not, then this fuse may be opened
(blown).
To replace the fuse:
1. Unscrew the end cap of the DC plug (counterclockwise).
2. Remove spring center contact and fuse.
3. Check fuse with a continuity checker.
4. If blown, locate a replacement 2 amp.
5. Replace the fuse, spring, contact and end cap.
6. Screw end cap clockwise until it is finger tight – DO NOT OVER-
TIGHTEN.
7. Test for proper operation of the 12 volt DC charging adapter.
Troubleshooting
Problem Possible Solution
Unit will not charge If the unit’s battery is deeply depleted, it
may require up to 96 hours of charging
using the AC method.
Make sure all of the unit’s functions are
turned off.
Make sure a suitable gauge extension
cord is properly connected to both the
unit and a functioning AC outlet.
or
Make sure the 12 volt DC charging
adapter is properly connected to both
the unit and a functioning DC power
source.
Check the connection to the AC or DC
power source.
Confirm there is a functioning AC or
DC current.
Check that the fuse in the 12 Volt DC
Adapter is not blown.
Problem Possible Solution
Unit fails to jump-start Make sure unit’s Jump Starter Power
Switch is in the on position.
Make sure a proper polarity cable
connection has been established.
Make sure the unit is not being operated
in the Compressor mode.
Check that the unit has a full charge.
Recharge the unit if necessary.
Portable Compressor
will not inflate
Make sure the Compressor Power
Button has been pressed to turn the
compressor on.
Make sure the unit is not being
operated in the Jump Starter mode.
Make sure the Sure Fit
®
nozzle is
securely screwed on to the valve stem
when attempting to inflate tires; or that
the nozzle adapter is securely screwed
into the Sure Fit
®
nozzle and is inserted
properly into the item to be inflated on
all other inflatables.
Check that the unit has a full charge.
Recharge the unit if necessary.
Problem Possible Solution
USB Port will not
power appliance
Make sure the USB Power Button is in
the on position.
Make sure all the USB Power/Fault
Indicators light solid blue. If a fault
condition exists in either of the USB
Ports, the USB Power/Fault Indicators
will flash blue. Refer to the Important
Notes in the “USB Ports” section to
remedy any faults.
Make sure that the total draw of all USB
devices plugged into the USB Ports
does not exceed 3.1A.
Some USB-powered household
electronics will not operate with this
USB charging/power port. Check the
manual of the corresponding electronic
device to confirm that it can be used
with this type of USB charging/power
port.
Check that the unit has a full charge.
Recharge the unit if necessary.
LED Area Light does
not come on
Make sure the Area Light Power Button
is in the on position
Check that the unit has a full charge.
Recharge the unit if necessary.
DXAEJ14_ManualENSP_010521.indd 20-21DXAEJ14_ManualENSP_010521.indd 20-21 1/5/2021 4:52:11 PM1/5/2021 4:52:11 PM