DIAMOND PRODUCTS Parts List Manual CC-110D-DC DEEP CUT SAW (December 2010) Part#: 1805082
CC-110D-DC RPM Chart ENGINE RPM BLADE SHAFT RPM 2,800 2,600 2,400 2,200 2,000 1,800 780 730 670 620 560 500 CC-110D-DC Specifications Dimensions: Length - 80" Width - 36" (including blade shaft) Weight - 2500 lbs Height - 60" Engine: 110 HP Cummins Diesel 4 Cylinder Liquid Cooled Blade Sizes: Maximum Blade Diameter - 72" Minimum Blade Diameter - 36" Blade Shaft RPM (see chart) Cutting Depth: Maximum 32.
Table of Contents Instruments and Controls 4 Frame Base and Covers 6 Blade and Jack Shaft Assembly 8 Transmission Assembly 10 Axle Assembly 12 Fan Assembly 14 Radiator Assembly 16 Air Filter Assembly 18 Engine and Muffler Assembly 20 Battery Assembly 22 Fuel Tank Assembly 23 Hydraulic Lift Assembly 24 Water Distribution Assembly 26 Service Recommendations 28 Recommended Spare Parts 29 Blade Arbor Template 30 Warranty 32
Instruments and Controls 4 Part No.
Frame Base and Covers 6 Part No. Qty.
Blade and Jack Shaft Assembly 8 Part No. Qty.
Part No. Qty.
Part No. Qty.
Fan Assembly 14 Part No. Qty.
Radiator Assembly 16 Part No. Qty. 2506458 3205560 6078042 2707325 6075198 2708009 2707318 2503263 2707319 2503909 2707321 2707320 2802760 2502624 6075146 2 5 1 1 1 1 1 4 1 1 1 1 6 1 1 Description 2-1/2 Dia.
Air Filter Assembly 18 Part No. Qty. 2506406 3205565 2506307 3205561 6048932 3201628 2500669 6075147 1 1 1 5 2 1 1 1 Description Air Cleaner Assembly 4-1/2 T-Bolt Clamp HG 90 Deg. Elbow Reducer 3.39-3.59 Hose Clamp Pipe, 3" O.D. x 3" Hose, 3" I.D. x 9-3/4" Hose Elbow, 3" I.D.
Part No. Qty. 2705408 2707327 3201170 2603308 6048933 2707228 6012006 2702952 2503482 2503516 2503517 2506430 2502653 2903169 2502661 2502662 2502654 2900499 2502652 2502660 2502566 2502567 2502666 2503243 2502669 1 1 1 1 1 1 1 1 1 1 1 5 1 6 1 2 1 4 1 1 1 1 1 1 1 Description Rain Cap Muffler Muffler Clamp Cummins 110hp Engine Key, 3/8" Sq. x 3/4" Male Spline Shaft Accessory Drive Pulley Female Spline Shaft Key, 5/8" x 3/8" x 2-1/2" 5 Groove Sheave Bushing V-Belts OB Housing M10 X 30 Hex HD.
Part No. Qty.
Part No. Qty. 2802888 2603322 3200551 3205628 3200323 3205736 3205737 3200899 3200897 2503344 3201501 3200296 2903143 2503495 2903143 2506304 2503495 2900729 6075022 2503530 1 1 4 1 2 2 2 1 1 1 1 1 1 1 1 2 1 1 1 1 Description Switch, 3 Position Hydraulic Pump 3/8" O-Ring to 1/4" M.
Water Distribution Assembly 26 Part No. Qty.
SERVICE RECOMMENDATIONS CHECK, CLEAN or REPLACE Radiator Filter Daily. (Part# 2502780) CAUTION Failure to maintain filter will cause engine to OVER HEAT Grease Daily Number of Pumps 12 12 6 6 2 6 6 Blade Shaft Bearings Jack Shaft Bearings Front Wheels Rear Axle Bearings Lift Cylinder Pin PTO Splines Pivot Bearings Qty 2 2 2 2 1 1 2 NOTE: Bearings in outboard support do NOT require any service Change engine oil every 100 hours. Change air filter every 100 hours.
CC-110D-DC Recommended Spare Parts Part No. Qty.
Electronic Systems cantrak 2600 and 2610 at a glance • 3.
cantrak 2600 and 2610 mounting and dimensional information specifications & technical data Hardware Micro Controller Siemens 164, 16 bit/ 20Mhz FLASH Memory 512K bytes RAM EEPROM 128K bytes 2600 - 2K bytes; 2610 2K + 32K bytes Electrical Display Resolution FSTN Power Requirements 10 to 32 VDC supply (reverse polarity protected) Power Consumption 40mA (backlight off) 160mA (backlight on) at 12VDC Audible Alarm 4kHz Internal sounder External output Open collector, internal driver (CANtrak 26
EQUIPMENT AND PARTS WARRANTY Diamond Products warrants all equipment manufactured by it against defects in workmanship or materials for a period of one (1) year from the date of shipment to Customer.
