ZHEJIANG MUSTANG BATTERY CO.,LTD TECHNICAL DATA SHEETS ZHE JIANG MUSTANG BATTERY CO., LTD No.818 Rongji road, Luotuo, Zhenhai district, Ningbo, P.R.China WEB: WWW.MUSTNAGBATTEY.COM TEL:0086-574-86593245 FAX:0086-574-86593227 NO.
Technical Data Sheet 1.Manufacturer: ZHEJIANG MUSTANG BATERY CO., LTD Address: No.818 Rongji road, Luotuo, Zhenhai district, Ningbo, P.R.China 2.Product identification: Applicable sizes: AA alkaline batteries Chemical name: alkaline battery Chemical system: Zn /MnO2 / KOH CAS No.: 7440-66-6 (% by weight): Zinc:25% ;MnO2:15%; KOH:10%;Steel;15%; Cadmium:15%;Other:20% 3.
Note 1: the contents of heavy metal (mercury, cadmium and lead) confirms to the requirements of 98/101/EC. Note 2: Manganese Dioxide (as Mn)---5mg/m3 (ceiling) (OSHA); 0.2mg/m 3 (as Mn/ ACGIH) Note 3: Carbon black---15mg/m3 (total dust, OSHA); 7.5mg/m 3 (respirable fraction, OSHA); 2.0mg/m 3 (ACGIH) ***These levels are not anticipated under normal consumer use conditions. ***ACGIH: American Council of Governmental Industrial Hygienists ***OSHA: Occupational Safety and Health Administration (U.
■stable Stability □unstable Polymerization Conditions to avoid □may occur ■will not occur Conditions to avoid Do not heat, crush, and disassemble, short circuit or recharge. Not applicable Incompatible materials Hazardous decomposition products Not applicable. Thermal degradation may produce hazardous fumes of zinc and manganese; such as hydrogen gas. Warning signals: not applicable. 6.
10.Work practices: 1.Handling and storage: Store at room temperature. Avoid mechanical or electrical abuse. Do not short or install incorrectly. Batteries may explode or vent if disassembled, crushed. Recharged or exposed to high temperatures. Install batteries in accordance with equipment instructions. Do not mix battery systems, such alkaline and zinc carbon, in the same equipment. Replace all batteries equipment at the same time. Do not carry batteries loose in pocket or bag. 2.
14.Ecological information: In general, no ecological data is available for preparations. Precautions avoid disposing into drainage systems and in the environment. IMDG NOT REGULATED 15.Disposable considerations: Do not dispose of into environment or into sewerage. If recycling is not possible, the product and its container have to be disposed of in accordance with your local legislation and regulations. 16.Transport information: Road: not regulated Air: not regulated Sea: not regulated.
19. Storage and stock rotation: ⑴For normal storage, the temperature should be between +10℃ and +25℃ and never exceed +30℃. Extremes of humidity (over 95% and below 40% relative humidity) for sustained periods should be avoided since they are detrimental to both batteries and packing. Therefore, batteries should not be stored next to radiators or boilers, in boxcars or direct sunlight, or next to other sources of heat.