Service manual

ManualsBrandsDimplex ManualsHome building and DecorDF2307SS

Service Manual

23” Compact Fireplace

Model Number:

DF2305

DF2307SS

DFB4047

DFB2306

DFS2308

UL Part Number

6901740000

7400080000R03

In keeping with our policy of continuous product development, we reserve the right to make changes without notice.

Dimplex North America Limited

1367 Industrial Road Cambridge ON Canada N1R 7G8

1-888-346-7539 www.dimplex.com

REV PCN DATE

02 - 5-DEC-11

03 28-JUN-13

IMPORTANT SAFETY INFORMATION: Always read this manual rst before attempting to service this

replace. For your safety, always comply with all warnings and safety instructions contained in this

manual to prevent personal injury or property damage.

DF2305 &

DF2307SS

DFB4047

DFB2306 &

DFS2308

Summary of content (11 pages)

PAGE 1
Service Manual 23” Compact Fireplace Model Number: DF2305 DF2307SS DFB4047 DFB2306 DFS2308 DF2305 & DF2307SS DFB2306 & DFS2308 UL Part Number 6901740000 DFB4047 IMPORTANT SAFETY INFORMATION: Always read this manual first before attempting to service this fireplace. For your safety, always comply with all warnings and safety instructions contained in this manual to prevent personal injury or property damage.
PAGE 2
TABLE OF CONTENTS Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Exploded Parts Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 3
OPERATION Remote Control Figure 1 A B C A - 3-Position Switch The power switch has two (2) On positions marked with “ I ” and “ II ”. The “ I ” position is for manual operation. In this position the built-in remote control is bypassed. The “ II ” position is for operating the unit with the provided remote control. When in “ II ” position the unit is operated with the ON and OFF buttons of the remote control. When the switch is in the center (“ O ”) position the unit is off.
PAGE 4
MAINTENANCE WARNING: Disconnect power before attempting any maintenance or cleaning to reduce the risk of fire, electric shock or damage to persons. Figure 3 Light Bulb Replacement CAUTION: Allow at least 10 minutes for light bulbs and heater assmebly to cool off before touching bulbs to avoid accidental burning of skin. Light bulbs need to be replaced when you notice a dark section of the flame. There are two (2) bulbs under the log set which generate the flames and embers.
PAGE 5
EXPLODED PARTS DIAGRAM 3 5 14 21 12 19 23 20 11 10 15 2 22 13 7 18 4 1 6 16 REPLACEMENT PARTS 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. Log Set Assembly. . . . . . . . . . . . . . . . 10438200700RP Flicker Motor. . . . . . . . . . . . . . . . . . . . . 2000220100RP Heater Assembly. . . . . . . . . . . . . . . . . . 2200490800RP Thermostat. . . . . . . . . . . . . . . . . . . . . . 2300150100RP Cutout. . . . . . . . . . . . . . . . . . . . . . . . . . 2300270100RP Heater Switch. . . .
PAGE 6
WIRING DIAGRAM MOD 0 - No Remote MOD A & B (Integral Remote) 6 www.dimplex.
PAGE 7
LIGHT HARNESS REPLACEMENT Tools Required: Phillips Head Screwdriver CAUTION: If unit was operating prior to servicing allow at least 10 minutes for lights, heating elements and top panel to cool off to avoid accidental burning of skin. WARNING: Disconnect power before attempting any maintenance to reduce the risk of electric shock or damage to persons. 1. Open the front control cover. 2. Remove front glass by removing the 2 outer screws holding the glass clips. (Figure 3) 3.
PAGE 8
! NOTE: A flat head screwdriver can be used to gently pry between the end of the connector and the switch to release the wires. 7. Remove the thermostat control knob by pulling straight out. 8. Remove the 2 mounting screws and replace the old thermostat with the new one. 9. Reassemble in the reverse order as above.
PAGE 9
at least 10 minutes for lights, heating elements and top panel to cool off to avoid accidental burning of skin. WARNING: Disconnect power before attempting any maintenance to reduce the risk of electric shock or damage to persons. 1. Open the front control cover. 2. Remove front glass by removing the 2 outer screws holding the glass clips. (Figure 3) 3. Remove the log grate by removing the 4 mounting screws. (Figure 5) 4. Remove the log set by lifting straight up. 5.
PAGE 10
TROUBLESHOOTING GUIDE PROBLEM CAUSE SOLUTION General Circuit breaker trips or fuse blows when unit is turned on Short in unit wiring. Trace wiring in unit. Improper circuit current rating Additional appliances may exceed the current rating of the circuit breaker or fuse. Plug unit into another outlet or install unit on a dedicated 15 amp circuit. Unit turns on or off by itself Remote Control has a similar frequency to other remotes in the area. Replace Remote Control.
PAGE 11
PROBLEM CAUSE SOLUTION Heater Heater is not turning off Heater is not turning on, but flame effect is still functioning Heater is turning off after a couple of minutes of operation Heater emits an odor Heater fan turns on but heater lacks heat Heating element is glowing red Heater fan runs continuously Improper operation Refer to Operation Section Defective Heater Switch Replace Heater Switch Defective Thermostat Replace Thermostat Improper operation Refer to Operation Section Loose wiring