Installation Sheet

ManualsBrandsDimplex ManualsHVAC31500 BTU Natural Gas Wall Mounted Heater with Wind Protection

Table Of Contents

Installation and User’s Guide

7216460100R00

Model

DGR32WNG

If you smell gas:

1. Shut off gas to appliance.

2. Extinguish any open ame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or re department.

DANGER

WARNING

FOR OUTDOOR USE ONLY.

Appliance is to be protected from rain.

TO BE INSTALLED ONLY BY AN

AUTHORIZED PERSON.

DANGER

Do not store or use gasoline, or other

ammable vapors and liquids, in the vicinity of

this or any other appliance.

An LP-cylinder not connected for use shall not

be stored in the vicinity of this or any other

appliance.

Improper installation, adjustment, alteration,

service, or maintenance can cause property

damage, injury, or death. Read the installation,

operating, and maintenance instruction

thoroughly before installing or servicing this

equipment.

WARNING

Share the warmth and leave a review.

dimplex.com/sharethewarmth

Your input helps to create even better

products and experiences.

We value your feedback!

5014095

INSTALLER : Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

Summary of content (20 pages)

PAGE 1
Model DGR32WNG Installation and User’s Guide 5014095 ! DANGER If you smell gas: 1. Shut off gas to appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. ! WARNING FOR OUTDOOR USE ONLY. Appliance is to be protected from rain. TO BE INSTALLED ONLY BY AN AUTHORIZED PERSON. ! DANGER Do not store or use gasoline, or other flammable vapors and liquids, in the vicinity of this or any other appliance.
PAGE 2
Table of Contents Welcome . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 IMPORTANT INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Package Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 3
Welcome Thank you and congratulations for choosing to purchase an Outdoor Radiant Natural Gas Heater. Please record your model and serial numbers for future reference. These can be found on the model and serial number label on your heater. Model MOD 65mm x 95mm Serial Number Glen Dimplex Americas Ltd 1367 Industrial Rd , Cambridge, ON, N3H 4W3, Canada Outdoor Radiant Gas Heater MODEL NO: DGR32WNG TYPE OF GAS: Natural Gas TOTAL INPUT: 31,500 BTU/HR GAS PRESSURE: 4 IN WC 5014095 Conforms to ANSI STD Z83.
PAGE 4
IMPORTANT INSTRUCTIONS ! WARNING Never use your gas heater in a garage, porch, shed, breezeway or any other enclosed area. Never obstruct the flow of ventilation air around your gas heater housing. ! WARNING Failure to comply with these instructions could result in a fire or explosion that could cause serious bodily injury, death or property damage.
PAGE 5
IMPORTANT INSTRUCTIONS Heater Installation Codes The installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2. Natural Gas (NG) Pressure The gas pressure regulator supplied with this appliance must be installed and used on your heater. The heater and regulator are set to operate with an outlet pressure of 4" W.C.
PAGE 6
IMPORTANT INSTRUCTIONS • This appliance is for outdoor use only. • This appliance must be securely mounted on a wall. • This appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection. • Any enclosure in which the appliance is used shall comply with one of the following: 1.
PAGE 7
Technical Specifications Model Heater Type Gas Type Test Point Pressure Nominal Gas Consumption Injector Size Hose Connection Product Dimensions Weight Approvals Country of Manufacture DGR32WNG Outdoor Radiant Natural Gas Heater Natural Gas 1.00 kPa 31,500 BTU/hr 1.40 mm*4 1/2" Female NPT Heater comes with factory-installed 1/2" Male NPT fitting on the gas regulator 25 1/2" × 16" × 11 1/2" (650 mm × 406 mm × 292 mm) 25.4 lb (11.
PAGE 8
Package Contents Image Description Quantity Heater Head with Regulator 1 Heat Deflector 1 Mounting Bracket 1 Black Cord 1 Red Cord 1 Pan Head Screw M6 x 10mm 2 Pan Head Screw M5 x 10mm 3 Pin 6 x 150mm 1 Bolt M6 x 150mm 1 R Cotter Pin 1 Wing Nut M6 1 Screwdriver 1 AA Battery 1 Hardware 8 www.dimplex.
PAGE 9
Accessories Please contact your dealer to purchase these accessories if they are required for your installation. Image Accessory Model Description DGRSHIELD Available for low clearance mounting, providing 12" (30.
PAGE 10
Installation RISK OF FIRE/ EXPLOSION • This heater should not be used in potentially explosive atmospheres. • Do not use in areas where gasoline, paint, or flammable liquids are used or stored. • Installation minimum clearances specified in this manual must be followed. • The heater must be installed in accordance with the manufacturer’s installation instructions. Minimum Clearances This appliance must only be used in a well ventilated area.
PAGE 11
Installation Read and perform the following pre-assembly instructions: 1. You may need assistance from another person to handle the heater. 2. Open carton and remove parts box and packing materials. Lay cardboard sheet on floor and use as a work surface to protect floor and heater parts from scratches. 3. Consult the Package Contents section to ensure all items are included and free of damage. 4. Do not assemble or operate the heater if it appears damaged.
PAGE 12
Installation 1 Install the heat deflector Figure 3 1. Install the heat deflector to the head assembly using 3 × hardware B. 2. Tighten all the screws. B ×3 If installing optional heat shield DGRSHIELD (sold separately): B 3. Secure the DGRSHIELD to the included heat deflector using the 4 bolts provided in the accessory kit. 2 Install the battery ×3 Figure 4 1. Insert the battery in the battery compartment. C C Figure 5 3 Secure the regulator hose 1.
PAGE 13
Installation 4 Figure 6 Install the wall-mounting bracket ! NOTE: If installing to the ceiling using DGRPOLE (sold separately), skip this step. 1. Secure the mounting bracket to the wall using 6 fasteners (not included). Ensure suitable mounting hardware for the wall material is used. This side up 5 Secure the heater to the mounting bracket Figure 7 1. Install the heater to the mounting bracket using hardware D, E, F, and G as shown. D E E F F G D 2.
PAGE 14
Operation Gas Requirements • This appliance is for use with natural gas only. • Ensure that inlet pressure to the regulator does not exceed 5.0 kPa. • The approved inlet pressure is 1.0 kPa. Natural Gas Safety Instructions 1. Your natural gas heater is designed for use with natural Figure 9 gas (NG) only. The gas pressure regulator supplied with this appliance must be installed and used on your heater. The unit and regulator are set to operate with an outlet pressure of 4" W.C. 2.
PAGE 15
Operation WARNING • Failure to read and follow the Operation instructions could result in a fire or explosion that could cause serious bodily injury, death or property damage. • If you have a gas leak that cannot be repaired by tightening, turn off the gas at the source, disconnect fuel line from your heater and call Technical Support or your gas supplier for assistance. • Inspect the heater and connections before each use.
PAGE 16
Operation WARNING • Before each use: - Inspect the heater for nests or other debris that could ignite to avoid the risk of fire, serious injury, or death. - Check all hoses for cracks, nicks, cuts, burns or abrasions. If a hose is damaged in any way, do not use your heater before replacing the hose with an authorized part from the Parts List.
PAGE 17
Maintenance WARNING • Turn off the gas supply before cleaning or servicing. • Do not attempt to service or clean heater while unit is operating. Ensure the heater is OFF and cool before cleaning. • To avoid the risk of burn or injury wait a minimum of 30 minutes for the heater to cool before attempting to clean or service. • There are no user-serviceable parts inside the heater. Any servicing other than cleaning of the heater should be performed by an authorized service representative.
PAGE 18
Troubleshooting ARNING: There are no user serviceable parts inside the heater. Any servicing other than cleaning of W the heater should be performed by an authorized service representative.
PAGE 19
Warranty One-Year Residential Limited Warranty Products to which this limited warranty applies This limited warranty applies to your newly purchased Outdoor Radiant Natural Gas Heater. This limited warranty applies only to purchases made in any province of Canada except for Yukon Territory, Nunavut, or Northwest Territories or in any of the 50 States of the USA (and the District of Columbia) except for Hawaii and Alaska.
PAGE 20
We value your feedback! Your input helps to create even better products and experiences. Share the warmth and leave a review. dimplex.com/sharethewarmth 1-888-346-7539 | www.dimplex.com In keeping with our policy of continuous product improvement, we reserve the right to make changes without notice.