5-Ton Electric Log Splitter MODEL # 100481 Operation Manual ! This safety alert symbol identifies important safety messages in this manual. Failure to follow this important safety information may result in serious injury or death.
For Service or Questions Call 1-877-487-8275 720-287-5182 www.dirtyhandtools.
Table of Contents Important Safety Information ......................................................4 Intended Use ...............................................................................4 Personal Protective Equipment ...................................................4 General Safety .............................................................................5 Safety Decals ...............................................................................5 Operation..................................
Important Safety Information ! WARNING WARNING: Read and thoroughly understand all instructions and safety information before assembling or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone to operate this log splitter who has not read this manual. As with all power equipment, a log splitter can be dangerous if assembled or used improperly. Do not operate this log splitter if you have doubts or questions concerning safe operation.
Important Safety Information ! DANGER GENERAL SAFETY Failure to follow warnings, cautions, assembly and operation instructions in the Operation Manual may result in serious injury or death. Read the Operation Manual before operation. •D o not permit children to operate this equipment at any time. Do not permit others that have not read and understood the complete Operation Manual to operate this equipment.
Operation PREPARATION OF THE LOG Both ends of the log should be cut as square as possible to prevent the log from rotating out of the splitter during operation. Do not split logs greater than 20 in. in length. ! WORK AREA DANGER • Do not operate the log splitter on icy, wet, muddy or otherwise slippery ground. ONLY operate your log splitter on level ground. Operating on a slope could cause the log splitter to roll over or logs to fall off of the equipment, which could result in injury.
Operation OPERATION OF THE LOG SPLITTER (Continued) ! DANGER •D o not straddle or step over the log splitter during operation. •D o not reach or bend over the log splitter to pick up a log. • Do not attempt to split two logs on top of each other. • Do not attempt to cross split a log. •D o not attempt to load your log splitter when the ram or wedge is in motion. • Use your hand to operate the control lever. Do not use your foot, a rope or any extension device.
Repair and Maintenance ! WARNING • Do not operate the log splitter when it is in poor mechanical condition or in need of repair. Frequently check that all nuts, bolts, screws, hydraulic fittings and hose clamps are tight. • ALWAYS unplug the power cable before performing any maintenance and repair. • Do not alter the log splitter in any manner. Any alteration will void the warranty and could cause the log splitter to be unsafe to operate. • Do not tamper with the engine to run it at excessive speeds.
Precautions FIRE PREVENTION ! CAUTION •D O NOT operate the log splitter near an open flame or spark. Hydraulic oil is flammable and can explode. •K eep a Class B fire extinguisher on hand when operating this log splitter in dry areas as a precautionary measure against possible flying sparks. TRANSPORTATION •D O NOT move this log splitter while the motor is running. •D O NOT carry any cargo or wood on the log splitter. •D O NOT not allow anyone to sit or ride on the log splitter.
Assembly Instructions This log splitter was completely assembled at the factory. The product has been filled with hydraulic oil at the factory. Refer to the photo and parts list should it become necessary to disassemble the unit for repair or replacement of parts. Remove the log splitter from the shipping container. Inspect it for shipping damage. If anything is damaged, contact your dealer or carrier.
Operating Instructions NOTE: This machine is only intended for homeowners and noncommercial users to split firewood as detailed in the instructions and not for any other purpose. NOTE: Ensure the power supply is not connected while preparing the log splitter for use. ! WARNING WARNING: Read and thoroughly understand all instructions and safety information before operating this log splitter. Failure to do so may cause serious injury or death.
Operating Instructions IMPORTANT: Before operating the log splitter turn the bleed screw as shown below one or two turns to allow air to be released from the hydraulic system. A flow of air through the bleed screw should be detectable while the log splitter is in use. Close the bleed screw after operation. Make sure that the bleed screw is closed before and during moving. Hydraulic fluid may leak through the bleed screw opening if the bleed screw is not fully tightened.
Operating Instructions ! WARNING Always wear safety glasses, safety shoes, and suitable work clothes when operating the log splitter. Do not wear neckties, scarfs or other loose clothing that could get caught in moving parts. Keep hands and feet clear of the ram and wedge at all times. Keep away from flammable liquids and gases before starting. 1) Place the log splitter on a sturdy, level surface. Block the wheels to prevent movement of the log splitter during operation.
Operating Instructions ! WARNING Always split the log along the grain of the wood. Splitting across the grain may cause some types of wood to burst or splinter resulting in possible injury. 100477 If a log becomes stuck on the wedge, remove both hands, unplug the log splitter from the power source and knock the log off of the wedge with a hammer. Do not attempt to dislodge the log with your hands. When finished splitting the logs, switch the motor off and unplug the power cable.
Operating Instructions MAINTENANCE 1) Switch off and unplug power cable before performing any maintenance, adjustment or repair. Make sure to remove any tools and accessories from the work area when done. 2) Always check the oil level of the hydraulic reservoir before operation. Operating the log splitter without an adequate oil supply will cause severe damage to the pump. 3) Wipe the unit after use with an oiled rag to prevent rust. 4) The hydraulic system is preset at the factory.
Warranty & Specifications IMPORTANT NOTICE We, the manufacturer, reserve the right to change the product and/ or specifications in this manual without notification. The manual is for information usage only and the pictures and drawings depicted herein are for reference only. Warranty Repair and Service Do not return this product to the store for warranty issues or repair. Call our customer service department at 720-287-5182, 1-877-487-8275, or visit www.dirtyhandtools.
