Safety Data Sheet (SDS) Revision date: December 15, 2021 SECTION 1: Identification of the substance / mixture and the company / undertaking 1.
1.4 Emergency telephone number Emergency phone: 1-800-535-5053 (Account# 84774) SECTION 2: Hazards identification 2.1 Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 [CLP] This product is considered as a manufactured article, and not classified as hazardous according to EC 1272/2008. Classification according to Directive 67/548/EEC This product is not classified as hazardous according to Directive 67/548/EEC.
SECTION 3: Composition/information on ingredients 3.1 Substances Product is a manufactured article. Exposure to interior of article is not expected with normal use. 3.2 Mixture Product is a manufactured article. Exposure to hazardous ingredients is not expected with normal use. Composition for Li-ion Cell (Model: IFR32650) used inside product. Chemical Name EC No CAS No. Weight (%) Lithium Iron Phosphate Graphite (C) --231-955-3 15365-14-7 7782-42-5 27.04 12.
Composition for Li-ion Cell (Model: 2770180E_30Ah_LFP) used inside product. Chemical Name EC No CAS No. Weight (%) Classification according to Regulation (EC) No. 1272/2008 [CLP] Lithium Iron Phosphate --15365-14-7 28-32 Not classified Graphite (C) 231-955-3 7782-42-5 13-17 Carc. 1A, H350 Carc. 2, H351 STOT RE 1, H372 Comb. Dust Aluminium (Al) 231-072-3 7429-90-5 15-19 Flam. Sol. 1 (H228) Water-react. 2 (H261) Copper (Cu) 231-159-6 7440-50-8 16-20 Acute Tox. 4 (Oral), H302 Comb.
Eyes Not an expected route of exposure. Following eye contact, cautiously rinse affected eye with clean lukewarm water for at least 30 minutes. Remove contact lenses, if present and easy to do. If eye irritation persists, seek medical attention. Skin Not expected to present as skin hazard under anticipated conditions of normal use. Following skin contact, immediately remove contaminated clothing and wash skin with copious amounts of soap and water. If irritation or pain persists, seek medical attention.
Unsuitable extinguishing media Do not use small quantities of water. If water spray is used, it must be continually applied until fire is extinguished. 5.2 Special hazards arising from the substance or mixture Battery may vent when subjected to excessive heat-exposing, fire or over voltage condition. Risk of explosion by fire is anticipated if batteries are disposed of in fire. Firefighting water runoff and dilution water may be toxic and corrosive and may cause adverse environmental impacts.
6.3 Methods and material for containment and cleaning up Add neutralizer/absorbent, e.g. sand or vermiculite, to spill area. Sweep or shovel spilled material and absorbent and place in approved container. Dispose of any non-recyclable materials in accordance with local, state, provincial or federal regulations. 6.4 Reference to other sections See Section 7 for more information See Section 8 for more information See Section 13 for more information SECTION 7: Handling and storage 7.
Derived No Effect Level (DNEL) / Predicted No Effect Concentration (PNEC) values Not applicable. Risk management measures according to used control banding approach Not applicable. 8.2 Ingredients with limit values Chemical Graphite (CAS #: Name 7782-42-5) Region Australia Austria Belgium Denmark 3 mg/m3 STEL: 10 mg/m3 TWA: 5 mg/m3 --TWA: 2.
Chemical Name 8.3 Graphite (CAS #: 7782-42-5) Copper (CAS #: 7440-50-8) Aluminium (CAS #: 7429-90-5) Region OSHA PEL Lithium, Hexafluorphosphate (LiPF6) (CAS #: 21324-40-3) --- --- --- NIOSH IDLH --- IDLH: 100 mg/m3 dust, fume and mist IDLH: 100 mg/m3 Cu dust and mist TWA: 1 mg/m3 dust and mist TWA: 0.
Color Odor Odor threshold pH Melting point / freezing point Initial boiling point / boiling range Flash point Evaporation rate Flammability Flammability limit in air Vapor pressure Vapor density Density Specific gravity Solubility in water Partition coefficient: n-octanol/water Auto-ignition temperature Decomposition temperature Viscosity Explosive properties Oxidizing properties 9.
900-0043 900-0042 900-0041 25.6 38.4 51.2 114 76 57 2918 2918 2918 590-0080 590-0086 590-0090 590-0097 IFR26650P 51.2 38.4 25.6 12.8 3.2 57 76 114 228 3.8 2918 2918 2918 2918 12 14-24-3000 14-36-3000 14-48-3000 / 44-48-3000 n/a n/a n/a n/a n/a SECTION 10: Stability and reactivity 10.1 Reactivity Stable under recommended storage and handling conditions (see Section 7, Handling and storage) 10.2 Chemical stability Stable under recommended storage conditions. 10.
Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Non-irritating to the skin under normal conditions No eye irritation under normal conditions No information available. No information available. Risk of exposure occurs only if the battery enclosure is compromised. Risk of exposure occurs only if the battery enclosure is compromised. No information available. No information available. No information available.
12.5 Results of PBT and vPvB assessment Not applicable. 12.6 Other adverse effects Batteries and cells released in the environment will slowly degrade and may release toxic or harmful substances. Batteries should be disposed or recycled according to local regulations. SECTION 13: Disposal considerations 13.1 Waste treatment methods Recycling is encouraged. Do not throw out a used battery or cell in the landfill. Electrolyte should not be dumped into any sewers, on the ground, or into any body of water.
.3 Hazard Class Air transport (ICAO/IATA) Sea transport (IMDG) Inland waterway transport (ADN) Land transport (ADR/RID) 14.
SECTION 15: Regulatory information 15.1 Safety, health, and environmental regulations/legislation specific for the substance or mixture Canada This is not a controlled product under WHMIS. This product meets the definition of a “manufactured article” and is not subject to the regulations of the Hazardous Products Act. All ingredients in the product are listed, as required, on the DSL/NDSL. This product does not contain any NPRI Substances.
SECTION 16: Other information This material Safety Data Sheet (SDS) complies with the requirements of Regulation (EC) No. 1907/2006. 16.
16.3 Manufacturer disclaimer THE INFORMATION ABOVE IS BELIEVED TO BE ACCURATE AND REPRESENTS THE BEST INFORMATION CURRENTLY AVAILABLE TO US. HOWEVER, DISCOVER ENERGY BATTERY MAKES NO WARRANTY OF MERCHANTABILITY OR ANY OTHER WARRANTY, EXPRESSED OR IMPLIED, WITH RESPECT TO SUCH INFORMATION, AND WE ASSUME NO LIABILITY RESULTING FROM ITS USE. USERS SHOULD MAKE THEIR OWN INVESTIGATIONS TO DETERMINE THE SUITABILITY OF THE INFORMATION FOR THEIR PARTICULAR PURPOSES.
