PL3000 PlasmaLift Installation & Owners Manual February 2007 sales@displaydevices.com (303) 412-0399 fax: (303) 412-9346 www.displaydevices.com 5880 N.
PL3000 PlasmaLift Installation Instructions Ensure the ceiling structure is capable of holding at least four times the combined weight of the lift (300 lbs.) and Plasma Display (74 – 140 lbs). This is a minimum requirement. Follow any local or state codes that apply to your specific area. 1.) 2.) 3.) 4.) 5.) 6.) 7.) 8.) 9.) 10.) 11.) If you have not already done so, install structural mounting points above the ceiling. For most installations, P3000 Unistrut® with all-thread works very well.
Cable Management Begin at fixed pivot point End point Loop under Loop over Loop under Begin at fixed pivot point 12.) 13.) Operate the lift up and down a few times to be sure that are no cables binding anywhere on the lift. Verify that when the door is shut it is level with the unit frame, if not adjust the all-thread arms on the left and right sides as needed.
PL3000 PlasmaLift Programming Show Position Programming can only be done with three-button control. If other methods of triggering the lift are normally used, first program the lift with the buttons and then configure lift for other trigger method. 1.) Press ‘HOME’ button. Unit raises to the home or stored position. 2.) Press and hold ‘STOP’ button for 10 seconds – unit is now in manual mode. 3.) Press ‘SHOW’ button momentarily – unit will travel down.
DRAWING REVISION BLOCK REV ECO DESCRIPTION DRAWN A - INITIAL RELEASE JTW JTW ECO-0310 UPDATED BOM ECO-0471 REPLACED TILT M OUNT WITH UNIVERSAL M OUNT JTW 4/18/ 2005 BSV 11/ 27/ 2006 B 38.00 WAS 36.00 - C D CHECKED APPROVED DATE 5/ 14/2003 10/ 17/ 2003 23.500 20.000 38.000 49.000 RETRACTED ISOMETRIC VIEW EXTENDED DISPLAY DEVICES, INC THE INFORMATION CONTAINED IN THIS DRAWING IS THE PROPERTY OF DISPLAY DEVICES, INC.
2 6 5 4 7 9 8 11 13 12 ITEM NO QTY PART NO 1 1 402-003 2 1 402-004 3 1 404-005 4 4 5900-12600 5 12 5950-12200 6 4 5950-13250 7 8 5900-13800 8 16 5950-12650 9 8 5950-13300 10 8 6000-11400 11 8 5900-15850 12 8 5950-12300 13 8 5950-10700 14 1 115-535 15 4 5900-20600 16 4 6000-13350 1 8 10 3 DISPLAY DEVICES, INC 16 5 15 THE INFORMATION CONTAINED IN THIS DRAWING IS THE PROPERTY OF DISPLAY DEVICES, INC.
