Operating instructions

ManualsBrandsDometi ManualsKitchen AppliancesRM1350

OPERATING

INSTRUCTIONS

RM1350

CANADA

Dometic, LLC

48 Zatonski, Unit 3

Brantford, ON N3T 5L8

CANADA

Phone: 519-720-9578

USA

Dometic, LLC

Service Ofce

2320 Industrial Pkwy.

Elkhart, IN 46516

Phone: 574-294-2511

Corporate Ofce

2320 Industrial Parkway

Elkhart, IN 46516

For Service Center

Assistance

Call: 800-544-4881

FOR YOUR SAFETY

If you smell gas:

1. Open windows.

2. Don’t touch electrical switches.

3. Extinguish any open ame.

4. Immediately call your gas supplier.

PAR MESURE DE SÉCURITÉ

Si on détecte une odeur de gaz :

1. Ouvrir les fenêtres.

2. Ne pas toucher les commutateurs électri-

ques.

3. Éteindre toute amme nue.

4. Contacter immédiatement le fournisseur

de gaz.

FOR YOUR SAFETY

Do not store or use gasoline or other am-

mable vapors and liquids in the vicinity of

this or any other appliance.

PAR MESURE DE SÉCURITÉ

Ne pas entreposer ou utiliser de l’essence

ou autre vapeur ou liquide inammable au

voisinage de cet appareil ou de tout autre

appareil ménager.

Im p ro p er in s ta l la t io n , ad ju s tm e nt ,

alteration, service or maintenance can cause

injury or property damage. Refer to this man-

ual. For assistance or additional information

consult a qualied installer, service agency

or the gas supplier.

Une installation, un réglage, une modication,

un dépannage ou un entretien, effectués in-

correctement, peuvent provoquer des blessu-

res ou des dommages matériels. Se reporter

à ce manuel. Pour obtenir une aide ou des

informations complémentaires consulter un

installateur qualié, une entreprise de dépan-

nage ou le fournisseur de gaz.

AVERTISSEMENT

If the refrigerator stops cooling - or - if

it emits an ammonia smell, immediately

turn the refrigerator off and contact a

Service Center.

Si le réfrigérateur cesse de refroidir - ou – s’il

s’en dégage une odeur d’ammoniac, arrêter

immédiatement le réfrigérateur et contacter

un centre de service après-vente.

AVERTISSEMENT

REVISION

Form No. 3313352.019 6/11

(Replaces 3313352.000)

(French 3313353.017)

LaGrange, IN 46761

Summary of content (30 pages)

PAGE 1
OPERATING INSTRUCTIONS RM1350 FOR YOUR SAFETY If you smell gas: 1. Open windows. 2. Don’t touch electrical switches. 3. Extinguish any open flame. 4. Immediately call your gas supplier. PAR MESURE DE SÉCURITÉ Si on détecte une odeur de gaz : 1. Ouvrir les fenêtres. 2. Ne pas toucher les commutateurs électriques. 3. Éteindre toute flamme nue. 4. Contacter immédiatement le fournisseur de gaz.
PAGE 2
-2-
PAGE 3
INTRODUCTION Thank you for purchasing a new Dometic refrigerator. This product is a recreational vehicle refrigerator intended for the storage of fresh and frozen foods, as well as making ice. Please read and be aware of possible safety hazards identified in this manual, and become familiar with the alert symbols on the refrigerator. Read this manual carefully so that you know how to operate the refrigerator safely and correctly. Keep this manual with the refrigerator for future reference.
PAGE 4
REFRIGERATOR OVERVIEW MODELS WITH THE MANUAL DOOR LOCKING SYSTEM Control panel LED display Airing position device (detachable) Ice box Door compartment Finned plate Shelf Drip protection Draining pipe Crispers General view of the appliance. Model shown is equipped with ice maker. The number of shelves and door compartments may vary according to the user’s requirements.
PAGE 5
REFRIGERATOR OVERVIEW MODELS WITH THE AUTOMATIC TRAVEL LATCH AND EQUIPPED WITH WATER DISPENSER Control panel LED display Ice box Automatic travel latch with integral airing position device Water dispenser Door compartment Finned plate Shelf Drip protection Draining pipe Crispers General view of the appliance. Model shown is equipped with ice maker and water dispenser. The number of shelves and door compartments may vary according to the user’s requirements.
PAGE 6
REFRIGERATOR OVERVIEW MODELS WITH THE AUTOMATIC TRAVEL LATCH AND EQUIPPED WITH ICE AND WATER DISPENSERS Control panel LED display Automatic travel latch with integral airing position device Ice box Drip tray Door compartment Finned plate Drip protection Draining pipe Shelf Crispers General view of the appliance. The number of shelves and door compartments may vary according to the user’s requirements.
PAGE 7
REFRIGERATOR OVERVIEW CONTROL PANEL 1 2 1. ON/OFF button (main power) Press the button to turn the refrigerator ON or OFF. Button In = Unit Is ON 3 Button Out = Unit Is OFF 2. AUTO/GAS mode selector button Press the button to turn the AUTO mode ON or OFF. Button In = Auto Mode (Attempts Electric Mode First) Button Out = Auto OFF (Attempts LP Gas Mode Only) 3. TEMP. SET button The thermostat has 5 settings where 1 indicates the warmest and 5 the coldest temperature setting.
PAGE 8
REFRIGERATOR OVERVIEW MODELS WITH THE AUTOMATIC TRAVEL LATCH 2. Gently close the doors (A) until the pins click into position (B). The refrigerator is equipped with a travel latch that automatically locks the refrigerator’s doors when the RV’s engine is running. When the RV’s engine is turned off, the latch unlocks the doors. A Pin Shutter To open one of the refrigerator doors while the engine is running, the travel latch must be manually unlocked. To unlock, simply slide the shutter to the left.
PAGE 9
REFRIGERATOR OVERVIEW MODELS WITH THE MANUAL DOOR LOCKING SYSTEM ABSORPTION COOLING SYSTEM When starting this refrigerator for the very first time, the cooling cycle may require up to four hours of running time before the cooling unit is fully operational. MANUAL LOCKING SYSTEM The refrigerator is equipped with a manual locking system. The doors are automatically locked when closed. To unlock, simply open the doors as usual.
PAGE 10
REFRIGERATOR OVERVIEW AUTOMATIC COOLING UNIT CYCLING SYSTEM AND LOW AMBIENT CONTROL The first automatic frost reduction cooling unit cycle begins 60 hours after turning ON the refrigerator (for best operational results the refrigerator should be turned on anytime between 4 and 10 PM), and will last for approximately 120 minutes. Thereafter, the cycle will automatically repeat every 48 hours as long as the refrigerator continues to run.
PAGE 11
INSTRUCTIONS FOR USE OPERATING THE ICE MAKER STARTING THE REFRIGERATOR RM1350IM, RM1350MIM, RM1350WIM & RM1350WID Before the ice maker can operate, make sure that: • The refrigerator is connected to 120 VAC . • The water valve supplying the refrigerator is turned on. • The ice level bail arm is in its fully down position. FIRE HAZARD. When the RV has not been used for some time, make sure that the path between the burner jet and the burner tube has not been obstructed before lighting the LP gas burner.
PAGE 12
INSTRUCTIONS FOR USE ADJUSTING THE SIZE OF CUBES 3. Turn the screw clockwise to decrease the cube size or if the mold is overfilling, and the cubes are stuck together. If the ice maker was cleaned and drained, no ice cubes will be dumped into the bin during the first cycle. To prevent overfilling, do not turn the adjustment screw more than one revolution at a time. Allow the ice maker to cycle several times before another adjustment is made.
PAGE 13
INSTRUCTIONS FOR USE TURNING OFF THE REFRIGERATOR, AND WHEN NOT IN USE. ICE DISPENSER (RM1350WID) Ice In order to provide a smooth and consistent flow rate of ice and to avoid ice spillage, please make sure to adjust the size of the ice cubes as described in ADJUSTING THE SIZE OF CUBES. You can turn off your refrigerator by pressing the main power ON/OFF button found on the control panel to the OFF position. This will shut off all power to the refrigerator, including DC power to the refrigerator.
PAGE 14
STORAGE COMPARTMENTS SHELVES 2. Slide the shelf to the left until bushings disengage, then tilt the shelf to one side at an angle while pulling forward. USING THE SHELF GUARDS To prevent food product containers from shifting, two sliding retainer bars are mounted on the shelves. These can be employed to separate the shelf into smaller sections which will hold the contents in place. Slide the shelf guards snugly against food item(s). The “front to back” shelf guard must be in upright position. 3.
PAGE 15
PRODUCT CARE DEFROSTING • Disconnect the water lines from the inlet and outlet sides of the water valve. Drain the lines into a cup and allow the lines to dry. • The ice maker and water reservoir should be drained and dried. Note that this procedure must be performed by a qualified service technician. • Using a lukewarm soda solution, clean the interior liner of the refrigerator. Clean the finned evaporator and shelves.
PAGE 16
MAINTENANCE & SERVICE CHECKING THE CONTROL SYSTEM To keep the refrigerator working properly, a qualified service technician should, at least once a year, inspect the connections, the control system, the LP gas pressure and flue baffle. Check the AMES control system by connecting/disconnecting the 120 VAC power, starting/stopping the engine, etc. CLEANING THE BURNER 1. Turn off the refrigerator 2. Unplug the power cord from the 120 VAC outlet.
PAGE 17
REFRIGERATOR REMOVAL Refrigerator removal and installation should be performed by a qualified service technician. Before removing the refrigerator: 1. Verify that the 120 VAC power cord is disconnected at the rear of the refrigerator. 2. Verify that the 12 VDC leads are disconnected and capped at the rear of the refrigerator. 3. Shut off the gas supply. 4. Disconnect and cap the LP gas line at rear of refrigerator. Always use a backup wrench when loosing and tightening LP gas connections.
PAGE 18
TROUBLESHOOTING TROUBLESHOOTING TABLE If you run into a problem, refer to the troubleshooting table below. If an error code is displayed, please see “Error Codes” for more information. SYMPTOM CHECK/REMEDIAL ACTION Refrigerator stops cooling • Immediately turn the refrigerator off and contact a Dometic dealer or Service Center. NOTE! Do not leave it running for an extended period of time, and never try to solve the problem by repeatedly restarting the refrigerator.
PAGE 19
TROUBLESHOOTING ERROR CODES For information about error codes, refer to the following table. The codes are displayed flashing (alternating between temperature and message). If an error code is displayed, contact a Dometic dealer or Service Center. After having solved the problem, turn refrigerator OFF and then back ON. The refrigerator will return to normal operation. ERROR CODES INFORMATION E0 No communication between display and power module.
PAGE 20
APPENDIX A - SPARE PARTS The following table displays commonly used parts which should be available from your Dometic Service Center.
PAGE 21
APPENDIX B - REARVIEW EQUIPMENT RM1350M 385 13 31−01 HVT J2 J3 F3 (5A) J1 SWITCHED 12V F4 (5A) LAMP TEST LINE AC HTR AC HTR NEUT LINE NEUT 12V DC D Power module RM1350IM, RM1350MIM & RM1350WIM 385 13 31−01 HVT J2 F3 (5A) J3 J1 SWITCHED 12V LAMP F4 (5A) TEST LINE AC HTR AC HTR NEUT LINE NEUT 12V DC D Thermostat Power module * Valid for refrigerators equipped with the automatic door locking system.
PAGE 22
APPENDIX B - REARVIEW EQUIPMENT RM1350WID Water hose Icemaker Heating cable Drain water hose Water hose Water dispenser door Control unit Heaters Protection plate Flexible cord Ice dispenser WARNING ! PART No.
PAGE 23
APPENDIX C - WIRING DIAGRAM RM1350M (MANUAL DOOR LOCK & DOOR INSERT PANELS OR STEEL DOORS) RM1350MIM (MANUAL DOOR LOCK, ICE MAKER & DOOR INSERT PANELS) 385149100 A A BROWN BLACK RED B K C FAN 9 H CIRCUIT BOARD POWER P1−1 P1−2 P1−3 9 9 G 3 1 10 1 10 P RELAY 87 P2 P4 P3 P1 3 1 Y 1 Y 4A 3 U 9 1 5 Z S 1 1 1 9 3 + 85 1 1 3 1 30 P7 1 3 3 86 7 1 3 M E J1 F3 3 N C° P5 F 1 3 J3 J2 P6 1 L 3 R 7 D 3 3 4 10 10 FAN J P2−1 P2−2 12V DC 3 V L N
PAGE 24
APPENDIX C - WIRING DIAGRAM RM1350IM (AUTOMATIC DOOR LOCK, ICE MAKER & STEEL DOORS) 385149200 A BROWN BLACK RED B K 9 9 9 E P4 P1 J1 P7 P5 F 7 F3 1 3 J3 J2 P6 1 L 3 10 3 1 3 3 1 1 1 1 N C° M 1 10 1 3 3 3 3 87 1 1 1 2 3 1 Y 5 V Z T 1 D+ 12V DC 4A 3 3 U 9 Y S + 85 30 1 3 P RELAY 9 1 9 1 86 R 7 G D 3 3 4 10 10 FAN J P2−1 P2−2 P3 FAN C H CIRCUIT BOARD POWER P1−1 P1−2 P1−3 P2 A L N 3 120 VAC 3 A WATER VALVE C C° X CONTROL B
PAGE 25
APPENDIX C - WIRING DIAGRAM RM1350WID (AUTOMATIC DOOR LOCK, ICE MAKER, WATER AND ICE DISPENSERS & DOOR INSERT PANELS OR STEEL DOORS) 385 14 94 BROWN BLACK RED B K C 9 9 9 P2−1 P2−2 4 P4 P1 7 F3 1 3 E J1 P7 F L 3 J3 J2 P6 1 P5 3 3 1 10 3 3 1 1 1 1 N C° M 1 10 1 3 3 3 3 1 RELAY 30 87 1 3 1 9 Y S 1 12V DC 4A A B C C° 9 9 X D U4 U3 E F V 3 1 9 G U1−1 U1−2 H J7−1 J7−2 I J K L J8−1 J8−3 J8−2 J8−4 M 5A N O P J1 J2 J3 J4 J5 J6 CONTROL MO
PAGE 26
APPENDIX D - CONSUMER SUPPORT Dometic website www.dometicusa.com Please visit the website for information and news about Dometic products. You can obtain information about how to get in contact, learn about product care, download manuals, leaflets and warranties. Service and spare parts For service and spare parts, please contact the Service Center Assistance, see the front page of this manual - or - visit the Dometic website to find the location of the nearest Dometic Service Center.
PAGE 27
APPENDIX E - DOMETIC WARRANTY Congratulations, and Thank You for purchasing the industry’s best built and best backed RV Refrigerator. Below you will find important warranty and maintenance information on Dometic’s exclusive two (2) year warranty. Please take a few moments and familiarize yourself with the program. We at Dometic appreciate your business and are confident that you will have many years of trouble-free RV enjoyment.
PAGE 28
APPENDIX F - MAINTENANCE SCHEDULE REFRIGERATOR OWNER MAINTENANCE YEARLY RECORD Customer Name: Address: City: Phone: Model No.: Serial No.
PAGE 29
PROTECTION FOR YOUR NEW INVESTMENT We truly appreciate that you have chosen to purchase a Dometic product for your recreational vehicle and we want to help you protect this wise investment. We at Dometic back our products with one of the most comprehensive warranties in the industry. Complete the registration card and mail to us or register your Product on-line at www.edometic.com.
PAGE 30
■■ WARRANTY VERIFICATION ■■ OWNER CONFIRMATION ■■ FACTORY COMMUNICATION ■■ 2 PLUS 3 SERVICE CONTRACT Your prompt registration records your right to protection under the terms and conditions of your warranty.  Returning your card or registering on-line guarantees you will receive product information and specials. Leaving your email address below will allow us to communicate with you quickly and efficiently.