User manual

ManualsBrandsDometic ManualsRefrigeratorRM3662

INSTALLATION AND

OPERATING INSTRUCTIONS

REFRIGERATOR FOR LP-GAS AND ELECTRIC OPERATION

RM 3662, RM 3663 RM 3862, RM 3863

Automatic-Manual Energy Selector

FOR YOUR SAFETY

If you smell gas:

1. Open windows.

2. Dont touch electrical switches.

3. Extinguish any open flame.

4. Immediately call your gas supplier.

FOR YOUR SAFETY

Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

WARNING: Improper installation,

adjustment, alteration, service or

maintenance can cause injury or

property damage. Refer to this

manual. For assistance or additional

information consult a qualified

installer, service agency or the gas

supplier.

AVIS

Cet appareil doit être réparé

seulement par un réparateur

autorisé. Modification de

lappareil pourrait être

extrèmement dangeruse, et

pourrait causer mal ou mort.

Contents:

Page

Installation 4

Operating Instructions 8

Maintenance & Service 12

Corporate Office

2320 Industrial Parkway Elkhart, IN 46515

USA For Service Center Assistance CANADA

Service Office Call: 800-544-4881 Dometic Distribution Inc.

Dometic Corporation 866 Langs Drive

509 South Poplar Street Cambridge, Ontario

LaGrange, IN 46761 N3H 2N7 Canada

Phone: 260-463-4858 Phone: 519-653-4390

822 70 13-05

Summary of content (20 pages)

PAGE 1
® INSTALLATION AND OPERATING INSTRUCTIONS REFRIGERATOR FOR LP-GAS AND ELECTRIC OPERATION RM 3662, RM 3663 RM 3862, RM 3863 Automatic-Manual Energy Selector FOR YOUR SAFETY If you smell gas: 1. Open windows. 2. Dont touch electrical switches. 3. Extinguish any open flame. 4. Immediately call your gas supplier.
PAGE 2
PAGE 3
Heater(s) Cover, Reigniter Flue baffle Power module cover Protection cover 12V DC Screw for protection cover 12 volt Terminal block FIG. 1 Burner jet Drain water hose Flexible cord D 2 - WAY display panel 3 - WAY display panel ON E COLD AUTO 1 OFF 2 GAS AC B C A D AUTO OFF AC GAS B B. AC Mode Indicator Lamp C. GAS Mode Indicator Lamp D. AUTO Mode Indicator Lamp E. CHECK Indicator Lamp (GAS Mode Only) F. Temperature Indicator Lamps G. Climate Control Switch H.
PAGE 4
INSTALLATION GENERAL INSTRUCTION This appliance is designed for storage of foods and storage of frozen foods and making ice. The refrigerators outlined herein have been design certified by A.G.A. under the ANSI Z21.19 Refrigerator Standard for installation in a mobile home or recreational vehicle and are approved by the Canadian Gas Association. The certifications are, however contingent on the installation being made in accordance with the following instructions as applicable. In the U.S.A.
PAGE 5
12 Volts DC Connection This refrigerator model require a continuous 12 volt DC supply to maintain the automatic energy system. The connection is made to the positive (+) and negative (-) terminals located at the rear of the refrigerator. (See FIG. 1). Correct polarity must be observed when connecting to the DC supply. Do not use the chassis or vehicle frame as one of the conductors. Connect two wires at the refrigerator and route to the DC supply.
PAGE 6
3 Hole for drain water hose FIG. 8 FIG. 6 2. Once the lower front strip is slipped under the hinge, the part is possible to swing into place as shown in FIG. 6. 3. Secure the refrigerator and the lower front strip with two screws: One screw through the hinge, and on the opposite side one screw through the lower front strip. (FIG. 6). STEP 2: Two screws installed in the top frame. The top decoration panel must be removed from the refrigerator before the screws can be installed.
PAGE 7
CERTIFIED INSTALLATION G Certified installations require one roof vent and one lower side vent. For Certified Vent System Kits see page 15. For further information contact your dealer or distributor. K K NOTE: The upper vent should be centered over the condenser coil at the back of the refrigerator. L FIG. 10 NOTE: Wood Strip MUST be in place Minimum ventilation height Condenser N M CLEARANCES FIG. 9 METHODS OF INSTALLATION The method of installation is shown in FIG. 9.
PAGE 8
Side view View from above C D D A H B W FIG. 11 Refrigerator Model RM 3662 inch RM 3663 mm RM 3862 inch RM 3863 mm Overall Dimensions Recess Dimensions Height A 54-21/32 Width B 24-7/8 Depth C 26-1/32 1388 60-51/64 632 24-7/8 661 26-1/32 1544 632 661 Height H 53-3/4 Width W 23-11/16 1365 602 59-15/16 23-11/16 1522 602 Depth D 24 610 24 610 This method of installation and these clearances will give you adequate space for service and proper installation.
PAGE 9
2-WAY display panel D ON E A COLD AUTO 1 OFF 3-WAY display panel 1 2 3 2 AC B GAS 4 5 COLDEST 3 CHECK C F START UP INSTRUCTIONS A. A continuous 12 volt DC supply must be available for the electronic control to function. B. Press the main power ON/OFF button (1) to the DOWN position. C. Press the TEMPERATURE SELECTOR button (3) 2-WAY Model or (4) 3-WAY Model until the lamp at the desired setting is illuminated. 2-WAY MODEL AUTO MODE 1.
PAGE 10
2-WAY display panel D ON E A COLD AUTO 1 OFF 3-WAY display panel 1 2 3 4 5 COLDEST 2 AC B GAS C 3 CHECK F ON DC D COLD AUTO 1 2 3 OFF AC GAS B E 1 2 3 4 5 COLDEST 4 CHECK C F THERMOSTAT DC MODE (3-way models only) The thermostat on the refrigerator, controls both the gas and electric operation, thereby eliminating the necessity of resetting each time a different energy source is employed.
PAGE 11
HOW TO USE THE REFRIGERATOR FOOD STORAGE COMPARTMENT The food storage compartment is completely closed and unventilated, which is necessary to maintain the required low temperature for food storage. Consequently, foods having a strong odor or those that absorb odors easily should be covered. Vegetables, salads etc. should be covered to retain their crispness. The coldest positions in the refrigerator are under the cooling fins and at the bottom of the refrigerator.
PAGE 12
GAS EQUIPMENT ASSEMBLY NUT SOLENOID VALVE . THERMOCOUPLE INLET FITTING MANUAL SHUTOFF VALVE . Shown in open position SPARK ELECTRODE PRESSURE TEST PORT . FIG. 12 BURNER JET . ELECTRIC EQUIPMENT CARTRIDGE HEATER The heat necessary for the operation of an absorption cooling unit is supplied by an electric heater mounted in a pocket of the boiler system. The 3-WAY Model is equipped with two electric heaters, one for 120 volt AC and one for 12 volt DC.
PAGE 13
B. Check all connections in the LP gas system (at the back of the refrigerator) for gas leaks. The LP gas supply must be turned on. Apply a non-corrosive bubble solution to all LP gas connections. The appearance of bubbles indicates a leak and should be repaired immediately by a QUALIFIED SERVICEMAN WHO IS FAMILIAR WITH GAS SYSTEM AND REFRIGERATORS. ! WARNING DO NOT use a wire or pin when cleaning the burner jet as damage can occur to the precision opening.
PAGE 14
H. LP gas pressure low at burner. Set main regulator so pressure does not drop below 11 inches of water column at pressure test port. (See FIG. 12). I. Burner not located properly under flue tube. Relocate. J. Burner damaged. Replace. K. Odor from fumes. 1. Dislocated burner 2. Damaged burner 3. Dirty flue tube L. FUSES 1. Refrigerator AC Supply 2. Refrigerator DC supply 3. Refrigerator control system See page 12, part FUSES. NOTE: AVOID SPRAYING WATER THROUGH THE REFRIGERATOR VENTS WHILE WASHING YOUR RV.
PAGE 15
1 1 1 2 3 3 1 1 1 4 5 CERTIFIED VENT SYSTEM KITS REFRIGERATOR MODEL KIT NO. RM 3662 RM 3663 4A COMPONENTS PART NO. Roof Base Roof Cover 3103633.XXX* 3103634.XXX* Lower Side Vent 3109350.XXX* RM 3862 RM 3863 * Fill in XXX with color code numbers. For color codes, contact your supplier. For further information contact your dealer or distributor.
PAGE 16
Positioning of shelves Put a screwdriver into the slot of the shelf lock. Turn the screwdriver counterclockwise. Remove the shelf locks from the wire shelf. Insert the ends of the wire shelf on the left-hand side at the desired position. Slide the wire shelf to the left. The right-hand side of the shelf will come loose. Slide the shelf into the holes on the right-hand side. Lower the right-hand side of the wire shelf and let the left-hand side slide out of the holes in the wall.
PAGE 17
RM 3662, RM 3862 RM 3663, RM 3863 17
PAGE 18
PAGE 19
PAGE 20
MO-FO 0233 20