Manual

DOWCO, Inc. Fax: [phone]
4230 Clipper Drive Phone: [phone]
Manitowoc, WI 54220 Website: www.dowcopowersports.com
Item 01071
Revised 12/8/06
Page 1
Printed in China
Installation Instructions
TANK BAG
Elite Sport Bike Luggage System
Please Read! Please read and understand these instructions completely before installation to avoid possible injury to
yourself, or damage to the accessory or vehicle. Read all Cautions, Warnings and Notes within installation instructions
and on bags. If you are unsure about securing the bag, please contact us at 1-800-558-7755 ext. 123. Monday through
Friday 8:00 am - 4:30 pm CST
1. PARTS LIST:
This Product contains the following components. Before beginning installation confirm there are no
missing or damaged components.
Item # Description Qty
1.
Tank Bag 1
2.
Strap 38” long w/(2) Hooks 1
3.
Strap 32” long w/(1) Male quick release buckle 1
4.
Map Pocket 1
2. PREPARATION:
Note: This product is supplied with a scratch resistant rubberized bottom layer. Care should be taken to avoid
gas spills and a heavy buildup of dust and/or dirt under the bag that may become embedded in the bottom
leading to scratches in the painted finish. Therefore the following preparation should take place before
mounting the luggage.
a. Place motorcycle on a secure stand.
b. Clean all mounting surfaces before beginning installation
.
3. INSTALLATION:
Note: This product is supplied with two mounting methods, Magnetic and Strap. You must choose which
mounting system is best for your application.
Mounting Tank Bag
Magnetic Mount Installation
a. Extend all magnetic flaps from tank bag.
b. Place and center magnetic unit directly on metal
tank. (Fig. 1)
c. Position magnetic flaps to conform to tank profile.
d. Insure that bag does not interfere with steering in
full left or right position.
* Overloading any Tank Bag will result in a high center of gravity which will cause bike to become top
heavy and susceptible to unexpected tipping, especially on lean-in, while negotiating high speed turns.
MAXIMUM ALLOWABLE LOAD LIMIT IS 5 LBS.
* Bags and straps must be installed so as not to interfere with full left or right steering. Failure to ensure
that adequate steering is available will result in serious injury
!
WARNING
Fig. 1
Flaps