Prism Plus Shower Enclosure & Base SHOWER ENCLOSURE & BASE INSTALLATION INSTRUCTIONS PLEASE REVIEW THIS ENTIRE MANUAL PRIOR TO INSTALLATION STEP 1: Install Shower Base STEP 2: Install Shower Enclosure 1-866-731-2244 For more information about DreamLine® products please visit DreamLine.
©2018 DreamLine. All Rights Reserved SLIMLINE SHOWER BASE SHOWER BASE DIMENSIONS AND INSTALLATION INSTRUCTIONS IMPORTANT DreamLine® reserves the right to alter, modify or redesign products at any time without prior notice for the purpose of product improvement and customer experience. Please refer to the model’s web page on DreamLine.com for the latest technical drawings, installation manuals, warranty information or additional product details.
©2018 DreamLine. All Rights Reserved Preparation 1. Prior to installation, examine all boxes and packages for shipping damage and compare the piece count with your packing slip. After opening all boxes and packages read this introduction carefully. Check that all of the parts are included in the package by checking off the components on the parts list.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine. All Rights Reserved Shower Base Cross Section Diagram Finished Wall Shower Base Cement board (2"×4") Stud Mortar Drain* * not included This product should be installed by someone familiar with the construction requirements for this type of project and the care necessary for the safe installation and operation of the product.
©2018 DreamLine. All Rights Reserved Shower Base Installation - Preparation 1. Ensure that the floor and the studs are at right angles. Provide a 5”×5” opening in the subfloor for the drain. The 2” PVC waste pipe should extend above the surface of the sub-floor according to the drain installation instructions and the height of the Shower base. Refer to the product drawings and tables in this installation manual for the drain location.
©2018 DreamLine. All Rights Reserved 2. Install the shower drain (NOT INCLUDED) according to the drain installation manual (supplied with the drain). (Fig 2) Fig 2 3. Place the tray into the designated position so that the Drain cutout drops around the Drain Pipe and butt the Shower Base up against the studs. (Fig 3) Lower the base over the drain pipe and set it into place against the studs.
©2018 DreamLine. All Rights Reserved 4. Level the tray and place marks on the studs above the upper edge of the tile flange. (Fig 4) Level base in two directions Fig 4 5. Mix the bedding material (Mortar, cement-sand mix, etc.) Concrete or plaster is not recommended. Apply enough bedding material to support the entire bottom of the shower base. This will add additional stability and prevent the base from shifting position.
©2018 DreamLine. All Rights Reserved 6. After the bedding material has been poured and before it sets, place the shower base into the position with the drain assembly sliding over the PVC waste pipe. It will be necessary to push the shower base until the top of the tile flange aligns with the marks drawn on the studs and the front edge is contacting the rough floor along the entire length of the shower base. Ensure that the base is level in all directions.
©2018 DreamLine.
©2018 DreamLine. All Rights Reserved Product Maintenance BASES and BACKWALLS: To ensure long lasting life for your acrylic base and/or back walls: wipe them off after each use with a soft cloth. To clean the acrylic base or back walls use non-abrasive sprays or cream-based cleaners. Avoid the use of aerosol spray cleaners. Never use abrasive cleansers, metal brushes or scrapers that could scratch or dull the surface.
TEL: 866-731-2244 FAX: 866-857-3638 DREAMLINE.COM For more information on DreamLine® Shower Doors and Enclosures please visit DreamLine.com ©2018 DreamLine.
PRISM PLUS ® d SHOWER ENCLOSURE INSTALLATION I e e n v NSTRUCTIONS i r L e s TO INSTALLATION PLEASE REVIEW THIS ENTIRE MANUAL PRIOR m e a R e r s t D gh © Ri All MODEL #s d e e in erv L s m e a R e r s t D gh © Ri All ® (Left-swing door installation shown) SHEN-2634340-## SHEN-2636360-## SHEN-2638380-## SHEN-2640400-## ##=finish 01- Chrome 04- Brushed Nickel 06- Oil Rubbed Bronze 09- Satin Black IMPORTANT! DreamLine® reserves the right to alter, modify or redesign products at any time without prior no
exclusive ClearMaxTM Glass technology. This is a specially formulated coating that prevents the build up of soap and water spots. Install the surface with the ClearMaxTM label towards the inside of the shower. Please note that depending on the model, the glass may be coated on either one or both surfaces. For best results, squeegee the glass after each use and dry with a ® soft cloth.
Section Title Checking Dimensions Important Information Model-Specific Preparation Tools Detailed Diagram of Shower Door Components Parts List Installation Steps Adjustable Hinge Information Product Maintenance Troubleshooting Factory Parts Information Page # d e e in erv L s m e a R e r s D ght © Ri All TIP ® 2 3 4 5 6 7-8 9-26 27 28 29 30 Measure the finished opening before proceeding with the installation to be sure the correct model size has been ordered d e e in erv L s m e a R e r s D ght © Ri
©2020 DreamLine® All Rights Reserved Checking Dimensions NOTE: This enclosure must be installed at the model size dimensions shown in Table A on page 2 and page 9. Be sure that the correct size shower enclosure has been ordered to fit the finished dimensions of the base or threshold where the enclosure will be installed. NOTE: The thickness of the finished wall treatment will affect where the enclosure will align upon the threshold.
d e e in erv L s m e a R e r s t D gh © Ri All IMPORTANT • • • DreamLine® reserves the right to alter, modify or redesign products any time without prior notice for product improvement and customer experience. Please refer to the model’s web page on DreamLine.com for the latest technical drawings, installation manuals, warranty information or additional product details.
©2020 DreamLine® All Rights Reserved ! Model-Specific Preparation REQUIRED: ±0.0 ±0.0 d e e in erv L s m e a R e r s D ght © Ri All ® ±0.0 ±0.0 ! ! DO NOT install the handle onto the door glass until instructed. Acrylic Tile TIP 1-1/2” minimum threshold DO NOT lift the glass using the handle. This could result in damage to the glass and/or serious personal injury. Always use an assistant or a professional grade glass suction cup when handling heavy glass.
©2020 DreamLine® All Rights Reserved Tools Tape Measure Level Pencil Drill bit (Ø1/8") (3mm) #2 Phillips Screwdriver d e e in erv L s m e a R e r s D ght © Ri All ® 100% Silicone* *Quick-drying/fast-curing silicone recommended for the installation of hinge panels. Power Drill #2 Phillips Driver Bit Drill bit Drill bit (Ø3/16") (Ø5/16") (4.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 Detailed Diagram of Shower Door Components d 13 e e n v i r L e s m e a R e r s D ght © Ri l l A ® 14 05 03 09 01 02 06 11 12 07 ® 17 04 e r n i L e s m e a sR e r D ght © Ri All d e v 08 15 6 (Left-swing door installation shown) © 2020 DreamLine® All Rights Reserved
©2020 DreamLine® All Rights Reserved Parts List 01 02 03 d e e v in x1 r x1 L e s m e a R e r s D 05ght 06 © Ri All ® Return Panel Glass 04 L-Bar™ Support Bracket (Right & Left) Hinge Panel Glass Door Glass x2 07 130º Glass-to-Glass Hinge Assembly x2 08 Wall Anchor 8mm (5/16”) 10 Decorative Cover and washer Handle ST4.
©2020 DreamLine® All Rights Reserved Parts List 13 14 15 d e e v in x1 r x1 L e s m e a R e r s D 17ght © Ri All ® 135º Strike Vinyl for 10mm (3/8”) glass Vinyl Seal with Flexible Fin for 10 mm (3/8”) glass 16 3mm/4mm Hex Key 1 ea ST4.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 1 Installation Steps ® ® d e d e e n v e Table A i r n v L i r e L s e m W1 W2 Glass Box Code s e m a e R a e rre ttss R! D h D ig h © g © ll R i R l l A A SHEN-GLP2601-343410 SHEN-GLP2601-363610 SHEN-GLP2601-383810 SHEN-GLP2601-404010 34" 36" 38" 40" NOTE: The Stainless Steel U-Channels (#11) must be installed at the correct dimensions for the model size indicated in Table A.
© 2020 DreamLine® All Rights Reserved 2 1d e e in erv L s m e a R e r s D ght © Ri All ® 2 W1 W2 d e e in erv L s m e a R e r Fig 2 s D ght © Ri All ® Parts Needed PRISM PLUS Shower Enclosure Manual Ver 2 012020 Tools Needed 10
3 1 ® 2* d e v e r n i L e s m e a R e Dr ghts © Ri All 3 W1 © 2020 DreamLine® All Rights Reserved Repeat Steps 2 and 3 for the opposite side of opening NOTE 4 W2 Fig 3 is present behind the wall: *◾Ifdrilla aStud ®up to the stud, Ø3/16”(4mm) hole d e e in erv NOTE L s m e a R e r s D ght © Ri All drill an Ø1/8” (3mm) pilot hole into the stud and use the ST4.
© 2020 DreamLine® All Rights Reserved 4 d e e in erv L s m e a R e r s D ght © Ri All ® inside inside Fig 4 5 1 d e e in erv L s m e a R e r s D ght © Ri All 2 ® Fig 5 Parts Needed Tools Needed (Left-hand swing installation shown) PRISM PLUS Shower Enclosure Manual Ver 2 012020 12
© 2020 DreamLine® All Rights Reserved 6 ® ved e r n i L e s m e a R e Dr ghts © Ri All 1 2 Fig 6a 23-15/16” ! d e e n v i r L e s m e a R e r s D ght 23-15/16” © Ri All ® The distance between the edges of both stationary panels needs to be 23-15/16” Tools Needed 23-15/16” (Left-hand swing installation shown) PRISM PLUS Shower Enclosure Manual Ver 2 012020 Fig 6b 13
© 2020 DreamLine® All Rights Reserved 7 (Overhead View) W2 d e e in erv L s m e a R e r s D ght © Ri All ® W1 23-15/16” d e e in erv L s m e a R e r s D ght © Ri All ® Tools Needed PRISM PLUS Shower Enclosure Manual Ver 2 012020 14
© 2020 DreamLine® All Rights Reserved 8 1 d e e in erv L s m e a R e r s D ght © Ri 2 All ® NOTE Repeat these steps to install the panel glass on the opposite threshold 3 d e e in erv L s m e a R NOTE e r s D ght © Ri All ® For installation into an Acrylic threshold: ◾ Drill an Ø1/8”(3mm) hole and use the ST4.2 x 40mm Countersunk Screws (#23). For installation into an Tile threshold ◾ Drill a Ø3/16” (4mm) hole up to the stud, drill an Ø1/8” (3mm) pilot hole into the stud and use the ST4.
© 2020 DreamLine® All Rights Reserved 9 *1 d e e n v i r L e s m e a R e Dr ghts © Ri 2 l Al ® *Fast-drying 100% silicone recommended for the installation of hinge panels. 3 d e e n v i r L e 5 s m e a R e Dr ghts © Ri All screw 4 NOTE washer Repeat these steps to install the panel glass on the opposite threshold. Maintain the required 23-15/16” spacing.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 L-Bar™ Installation ® 10 4.6 4.5 4.8 4.4 4.7 d e e in erv L s m e a R 05 Dre s t h © Rig l l A 4.2 4.3 4.1 Left-handed L-Bar™ Support Bracket shown Fig 10 d e e n v i r L e s m e a sR e r D ght © Ri l l A ® Item 4.1 4.2 4.3 4.4 4.5 4.6 4.7 4.8 Item Description PVC Spacer 0.5 mm M5 Rubber-Tipped Set Screw L-Bar™ Bracket L-Bar™ Bracket Decorative Cover Wall Anchor L-Bar™ Bracket Wall Plate Truss Head Screw ST4.2×40 M5×14.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 11 1 5 3 d e e n v i r L e s m e a R e r s D ght © Ri l l A ® 2* 6 7 d e e n v i r L e s m e a R e r s D ght © Ri All Fig 11 4 Leave 1/16”-1/8” space between Bracket Wall Plate (#4.6) and U-Channel ® (Left-hand L-Bar™ Support Bracket shown) TIP *Leave the L-Bar™ decorative cover attached when marking the L-Bar™ position on the wall to allow space (1/16”-1/8”) to re-attach the cover plate after installation.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 12 1 d e 3* e n v i r L e s m e a R e Dr ghts © Ri All ® 2 Max 3/16” (4mm) 4* Max 3/16” (4mm) 5 d e e n v i r L e s m e a R e Dr ghts © Ri All ® (Left-hand L-Bar™ Support Bracket shown) * To adjust the angle of the L-Bar™: NOTE Loosen the M5 x 14.5 screws, rotate the appropriate set screw (See Fig 12.3 and 12.4) to adjust the angle of the L-Bar™ (up to 3/16” (4mm)) in the desired direction. Hand tighten the M5 x 14.
© 2020 DreamLine® All Rights Reserved 13 23-15/16” d e e in erv L s m e a R e r s D ght © Ri All ® 23-15/16” Return Panel Glass (#01) Fig 13 Lorem ipsum (Left-hand swing installation shown) TIP NOTE ! Before installing the Door glass (#02), attach the 135° Strike Vinyl (#14) to the edge of the Return Panel Glass (#01) to protect the edge of the glass during installation of the Door Glass (#02).
1 © 2020 DreamLine® All Rights Reserved 14 id e I ns 2mm hinge gaskets d e e in erv L s2 m e a R e r s D ght © Ri All ® hinge panel 2mm hinge gaskets Door glass 3 Install the hinges flush with the edge of the Door Glass Fig 14a Hin g pan e gla el ss d e e in erv L s m e a R e r s D ght © Ri All ® Door Glass NOTE Use 13/16” shims (not included) beneath the door glass to help align the door glass with the hinge openings and the tops of the Panel Glass.
© 2020 DreamLine® All Rights Reserved NOTE These adjustable hinges are factory set to overclose for a tight seal. See Page 26 for instructions regarding the adjustment features of these hinges.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 Vinyl Seal Installation 16 2 d e e in erv L s m e a R e r s D ght © Ri l l A 1 ® 3 Fig 15 d e e n v i r L e s m e a R e r s D ght © Ri All ® Inside NOTE The deflector strip on the Sweep Vinyl must be installed toward the inside of the shower Parts Needed Deflector Strip 23 © 2020 DreamLine® All Rights Reserved
© 2020 DreamLine® All Rights Reserved PRISM PLUS Shower Enclosure Manual Ver 2 012020 Vinyl Seal Installation (Cont’d.
d e e n v i r L e 2 s m e a R e r s D ght © Ri l l A 1 Notch vinyl to fit around back side of hinge Slit soft vinyl flap Slice the soft vinyl flap with a razor knife where the hinge and glass meet hinge panel Notch bottom of vinyl to fit around back side of the hinge door 3 Slice the soft vinyl flap with a razor knife where the hinge and the glass meet Notch top and bottom of vinyl to fit around back of hinge and around the sweep vinyl.
© 2020 DreamLine® All Rights Reserved 19 Surfaces need to be clean and free of debris before applying silicone. Apply to the entire interior perimeter of the panel glass. NOTE d e e in erv L s m e a R e r s D ght © Ri All ® 24 Hours d e e in erv L s m e a R e r s D ght © Ri All ® ! Allow 24 hours for the silicone to cure before using shower.
© 2020 DreamLine® All Rights Reserved 130° Adjustable Hinge Information HG-PRS30A 130° Adjustable Hinge NOTE The hinge assemblies are preset to overclose 5° beyond the normal closing position to create a tight seal against the strike vinyl. The adjustment feature on the hinge assemblies can be used to change the closing angle of the door only. Make any hinge adjustments prior to installing the Strike Vinyl.
©2020 DreamLine® All Rights Reserved Product Maintenance BASES and BACKWALLS: To ensure long lasting life for your acrylic back walls: wipe them off after each use with a soft cloth. To clean the acrylic back walls use non-abrasive sprays or cream based cleaners. Avoid the use of aerosol spray cleaners. Never use abrasive cleansers, metal brushes or scrapers that could permanently scratch or dull the surface.
©2020 DreamLine® All Rights Reserved Troubleshooting Problem/Symptom Suggested Solution •Check all shipping/packaging material for missing parts/components. •If not found, contact DreamLine Customer Support (1-866-731-2244) to order factory part replacement. ® Missing Parts d e e n v i r L e s m e a R e Dr ghts © Ri All Water Leaks/Stationary Panels Water Leaks/Door Glass Door Glass does not create a good seal when closed. Door Glass does not open or close smoothly.
PRISM PLUS Shower Enclosure Manual Ver 2 012020 Factory Parts Information d e e n v i r L e s m e a R e r s D ght © Ri l l A SHEN-GLP2601 PRISM PLUS ITEM # 01 02 03 FACTORY PART NUMBER ® FACTORY PARTS INFORMATION ITEM DESCRIPTION QTY 014352028 Return Panel Glass (34" x 34") 1 014352021 Return Panel Glass (36" x 36") 1 014352023 Return Panel Glass (38" x 38") 1 014352025 Return Panel Glass (40" x 40") 1 014352026 Door Glass 1 014352027 Hinge Panel Glass (34" x 34") 1 014352020 H
NOTES: d e e in erv L s m e a R e r s t D gh © Ri l l A ® d e e in erv L s m e a R e r s t D gh © Ri l l A ® ©2020 DreamLine® All Rights Reserved
NOTES: d e e in erv L s m e a R e r s t D gh © Ri l l A ® d e e in erv L s m e a R e r s t D gh © Ri l l A ® ©2020 DreamLine® All Rights Reserved
NOTES: d e e in erv L s m e a R e r s t D gh © Ri l l A ® d e e in erv L s m e a R e r s t D gh © Ri l l A ® ©2020 DreamLine® All Rights Reserved
d e e in erv L s m e a R e r s t D gh © Ri l l A ® d e e in erv L s m e a R e r s t D gh © Ri l l A ® TEL: 866-731-2244 FAX: 866-857-3638 DREAMLINE.COM For more information on DreamLine® Shower Doors and Enclosures please visit DreamLine.