Safety Data Sheet

Formula 65
SAFETY DATA SHEET
DUNLOP
Section 8: Exposure Controls/personal protection
Section 6 Accidental Release Measures
Use Gloves, Goggles, Boots and Breathing Mask. Small amounts do not need special measures.Clean up with water. For
large spills remove all sources of ignition. Ventilate area. Absorb with an inert absorbent material. Avoid runoff into drains
and sewers.All used and unused product should be disposed of in conformance with local, state, and federal regulations
Section 7 Handling and Storage
Store materials tightly closed and away from sunlight, warm confined spaces, heat and open flame. Never weld on or near
containers either empty or full. Secure all chemicals out of the reach of children.
Control
p
arameters
Occu
p
ational ex
p
osure limits
In
g
redient name
1000ppm
PEL/OSHA TLV-ACGIH
1000ppm
Polydimethylsiloxane- Biodegradable N/E
N/E
Personal precautions, protective equipment and emergency procedures
For non-emergency
personel:
No action shall be taken involving any personal risk or without suitable training.Evacuate surrounding
areas. Keep unnecessary and unprotected personnel from entering. Do not touch or walk through spilled
material. Shut off all ignition sources. No flares, smoking or flares in hazard area. Avoid breathing vapor
or mist. Provide adequate ventilation. Wear appropriate respirator when ventilation is inadequate. Put on
appropriate personal protective equipment.
For emergency
responders:
If specialised clothing is required to deal with the spillage, take note of any information in Section 8 on
suitable and unsuitable materials. See also the information in for "For non-emer
g
enc
y
personnel".
Environmental
p
recautions:
Avoid dispersal of spilled material and runoff and contact with soil, waterways, drains and sewers. Inform
the relevant authorities if the
p
roduct has caused environmental
p
olllution
(
sewers, waterwa
y
s, soil or air
)
Methods and materials for containment and cleaning up
Small
spill:
Stop leak if without risk. Move containers from spill area. Dilute with water and mop up if water soluble.
Alternatively, or if water-insoluble, absorb with an inert dry material and place in an appropriate waste disposal
container. Use spark-proof tools and explosion-proof equipment. Dispose via a licensed waste disposal contractor.
Large
spill:
Stop leak if without risk. Move containers from spill area. Prevent entry into sewers, water courses, basements or
confined areas.Wash spillages into an effluent treatment plant or proceed as follows. Contain and collect spillage
with non-combustible, absorbent material e.g. sand, earth, vermiculite or diatomaceous earth and place in
container for disposal according to local regulations (see Section 13). Use spark-proof tools and explosion-proof
equipment.Dispose via a licensed waste contractor. Contaminated absorbent material may pose the same hazard
Precautions for
safe handling:
Put on appropriate protective equipment (see Section 8). Do not get in eyes or on skin or clothing.
Do not ingest. Avoid breathing vapor or mist. Keep in the original container or an approved alternate
made from a compatible material, keep tightly closed when not in use. Store and use away from heat,
sparks, open flame or any other ignition source. Do not reuse container. Wash throughly after use.
Conditions for safe
stora
g
e:
Store in original container protected from direct sunlight in a dry, cool and wellventilated area, away
from incom
p
atible materials
(
see Section 10
)
and food and drink. Do not store in unlabeled
Appropriate engineering
controls
No special ventilation requirements. Good general ventilation should be sufficient to
control worker ex
p
osure to airborne contaminants
Individual protection measures
H
yg
iene Measures: Wash hands forearms and face throu
g
hl
y
after handlin
g
chemical
p
roducts
E
y
e/face
p
rotection: wear chemical safet
y
g
o
gg
les and face shield.
Skin
p
rotection: Avoid skin contact. Wear
g
loves im
p
ervious to conditions of use.
Respiratory protection: Use a properly fitted, air-purifying or air-fed respirator complying with an
approved standard if a risk assessment indicates this is necessary.
Page 3 of 5
CAS #
64-17-5
63148-62-9
Ethyl Alcohol